HomeMy WebLinkAbout39947-Z ip', Town of Southold 1/12/2016
' P.O.Box 1179
53095 Main Rd
Southold, New York 11971
CERTIFICATE OF OCCUPANCY
No: 38035 Date: 1/12/2016
THIS CERTIFIES that the building GENERATOR
Location of Property: 57856 Route 25, Southold
SCTM#: 473889 Sec/Block/Lot: 66.-2-2.5
Subdivision: Filed Map No. Lot No.
conforms substantially to the Application for Building Permit heretofore filed in this office dated
7/8/2015 pursuant to which Building Permit No. 39947 dated 7/14/2015 •
was issued, and conforms to all of the requirementsof the applicable provisions of the law. The occupancy for
which this certificate is issued is:
ACCESORY GENERATOR AS APPLIED FOR
•
The certificate is issued to Marciano,Giovanni
of the aforesaid building.
SUFFOLK COUNTY DEPARTMENT OF HEALTH APPROVAL
ELECTRICAL CERTIFICATE NO. 39947 01-12-2016
PLUMBERS CERTIFICATION DATED
Authorized Signature
,. TOWN OF SOUTHOLD
BUILDING DEPARTMENT
TOWN CLERK'S OFFICE
theU SOUTHOLD, NY
\44oi f '-
BUILDING PERMIT
(THIS PERMIT MUST BE KEPT ON THE PREMISES
WITH ONE SET OF APPROVED PLANS AND SPECIFICATIONS
UNTIL FULL COMPLETION OF THE WORK AUTHORIZED)
Permit#: 39947 Date: 7/14/2015
Permission is hereby granted to:
Breyer, Thomas & Breyer, Maria
57856 Route 25
Southold, NY 11971
To: Install a generator as applied for.
At premises located at:
57856 Route 25, Southold
SCTM # 473889
Sec/Block/Lot# 66.-2-2.5
Pursuant to application dated 7/8/2015 and approved by the Building Inspector.
To expire on 1/12/2017.
Fees:
ACCESSORY $100.00
ELECTRIC $85.00
CO -ACCESSORY BUILDING $50.00
Total: $235.00
Bu :• • Inspector
Form No.6
TOWN OF SOUTHOLD
BUILDING DEPARTMENT
TOWN 14A LL
765-1802
APPLICATION FOR CERTIFICATE OF OCCUPANCY
•
This application must be filled in by typewriter or ink and submitted to the Building Department with the following:.
A. For new building or new use:
I. Final survey of property with accurate location of all buildings, property lines,streets,and unusual natural or
topographic features.
2. Final Approval from Health Dept. of water supply and sewerage-disposal(S-9 form).
3. Approval of electrical installation from Board of Fire Underwriters.
4. Sworn statement from plumber certifying that the solder used in system contains less than 2/10 of 1%lead.
5. Commercial building, industrial building,multiple residences and similar buildings and installations,a certificate
of Code Compliance from architect or engineer responsible for the building.
6. Submit Planning Board Approval of completed site plan requirements.
B. For existing buildings(prior to April 9, 1957) non-conforming uses,or buildings and"pre-existing"land uses:
1. Accurate survey of property showing all property lines,streets,building and unusual natural or topographic
features.
2. A properly completed application and consent to inspect signed by the applicant.If a Certificate of Occupancy is
denied,the Building Inspector shall state the reasons therefor in writing to the applicant.
C. Fees
1. Certificate of Occupancy-New dwelling$50.00,Additions to dwelling$50.00,Alterations to dwelling$50.00,
Swimming pool$50.00,Accessory building$50.00,Additions to accessory building$50.00,Businesses$50.00.
2. Certificate of Occupancy on Pre-existing Building- $100.00
3. -Copy of Certificate of Occupancy-S25
4. Updated Certificate of Occupancy- $50.00
- 5.---Temporary-Certificate.of.Occupancy—Residential$15.0.0,.Commer_cial_$15.00._ _..__. _.___.
Date. -7//- /�
New Construction: Old or Pre-existing Building: (check one)
Location of Property:-577g),..52:6 l7� /VAZ) • 5e76 '
House No. ,,/ Street Hamlet
_
Owner or Owners of Property: T2/�/`
Suffolk County Tax Map No 1000, Section Block Lo 2.5
Subdivision Filed Map. Lot:
Permit No. 39/(4-7 Date of Permit. Applicant:
Health Dept. Approval: Underwriters Approval:
Planning Board Approval:
Request for: Temporary Certificate Final Certificate: ✓ (check one)
Fee Submitted: $ 50 - '2
Applicant Signature
oe••.aapF SO(/Tyo
o
Town Hall Annex �� ~ : Telephone(631)765-1802
54375 Main Road ; illiiiii Z Fax(631)765-9502
P.O. Box 1179 : `o
roger.richert(a�town.southold.ny.us
Southold,NY 11971-0959 : �' �O s
- I1
.COUNIO '..
•—•see. o''.
BUILDING DEPARTMENT
TOWN OF SOUTHOLD
CERTIFICATE OF ELECTRICIAL COMPLIANCE
SITE LOCATION
Issued To Marciano
Address: 57856 Route 25 City. Southold St: New York Zip. 11971
Building Permit it 39947 Section. 66 Block: 2 Lot: 2.5
WAS EXAMINED AND FOUND TO BE IN COMPLIANCE WITH THE NATIONAL ELECTRIC CODE
Contractor: DBA: North Electric LLC License No: 890-ME
SITE DETAILS
Office Use Only
Residential X Indoor Basement Service Only
Commerical Outdoor X 1st Floor Pool
New Renovation 2nd Floor Hot Tub
Addition Survey Attic Garage
INVENTORY
Service 1 ph Heat Duplec Recpt Ceiling Fixtures HID Fixtures
Service 3 ph Hot Water GFCI Recpt Wall Fixtures Smoke Detectors
Main Panel NC Condenser Single Recpt Recessed Fixtures CO Detectors
Sub Panel NC Blower Range Recpt Fluorescent Fixture Pumps
Transformer Appliances Dryer Recpt Emergency Fixtures Time Clocks
Disconnect Switches Twist Lock Exit Fixtures TVSS
Other Equipment: 48 KW Stand by Generator with Auto Transfer Switch
Notes:
i:7jInspector Signature: Date: January 12, 2016
Electrical 81 Compliance Form.xls
FIELD II SPEC oN REPORT DATECOMMF TS `
•
FOUNDOION(1ST) . . J
CI
FOUNDATION(2ND) -- . • .
•
. : , . .. ,,.T--..
- o
•. ' . ' •
•
•
r rH•
•
•
• c
•
ROUGH FRAMPIG& r
• • . • .
PLUMBING ..
• s
•
INSULATION PER N.Y. •
•
H
STATE ENERGY COTe .•• . '
• , •
• ♦ ,. . . .i . . • . ,
_. . .. �.' . . ' . . , ' I -
. _ . "` - r j
FINAL
A T
Y •� ..
• . ♦ ,r. .
• .� r
TS
-N = 'S •
-tm
•
r 7;
NO
J
TOVirN,OF SOUTHOLD BUILDING PERMIT APPLICATION CHECKLIST
BUILDING DEPARTMENT Do you have or need the following,before applying?
TOWN HALLBoard of Health
SOUTHOLD,NY_ 971 4 sets of Building Plans
TEL: (631)765-1802 Plannmg Board approval
FAX: (631) 765-9502 Survey
Li-
SoutholdTown.NorthFork.net PERMIT NO. I l 7 � Check
Septic Form
N Y S.D.E.0
Trustees
6DD C CI� VC O Application
C; , Flood Permit
Examined I ` it ,201 LJ I Single&Separate
L.. }I
tormWaterAssessment Form
L; JUL -6 1015 ContactApproved 1 `9- ,20 Mail to./JjG,!.". , /) b
BLDG. DEPT ?oWLL-e>,,Q,,C /�i9�//AS
Disapproved a/c L.._ . f0.'r:Of SOUTNOLD /
_
Phone
'4 3j�-J/,�-' ?�
Expiration l ` 9— ,20 ` 1
IA IL Bui ' : P- •ector
APPLICATION FOR BUILDING PERMIT
Date..JZi9' , 20/-5-
INSTRUCTIONS
SINSTRUCTIONS
a. This application MUST be completely filled in by typewriter or in ink and submitted to the Building Inspector with 4
sets of plans,accurate plot planto scale. Fee according to schedule.
b. Plot plan showing location of lot and of buildings on premises,relationship to adjoining premises or public streets or
areas,and waterways.
c. The work covered by this application may not be commenced before issuance of Building Permit.
d.Upon approval of this application,the Building Inspector will issue a Building Permit to the applicant. Such a permit
shall be kept on the premises available for inspection throughout the work.
e. No building shall be occupied or used in whole or in part for any purpose what so ever until the Building Inspector
issues a Certificate of Occupancy.
f. Every building permit shall expire if the work authorized has not commenced within 12 months after the date of
issuance or has not been completed within 18 months from such date. If no zoning amendments or other regulations affecting the
property have been enacted in the interim,the Building Inspector may authorize,in writing,the extension of the permit for an
addition six months. Thereafter,a new permit shall be required.
APPLICATION IS HEREBY MADE to the Building Department for the issuance of a Building Permit pursuant to the
Buildmg Zone Ordinance of the Town of Southold, Suffolk County,New York,and other applicable Laws,Ordinances or
Regulations,for the construction of buildings,additions,or alterations or for removal or demolition as herein described. The
applicant agrees to comply with all applicable laws,ordinances,building code,housing code,and regulations,and to admit
authorized inspectors on premises and in building for necessary inspections.
Y>
(Signature of applicant or name,if a corporation)
/70 1•W.Z.Z.ev,P";27,9 ,L'',,�i9/1'�
(Mailing address of applicant) ,/d
State whether applicant is owner,lessee, agent, architect, engineer, general contractor,electrician,plumber or builder
.76 /1/7.-
Name of owner of premisest7diy/1//47,57 ./...9/V0
(As on the tax roll or latest deed)
If applicant is a corporation, signature of duly authorized officer
(Name and title of corporate officer)
Builders License No ..5.73 .513—/7
Plumbers License No. 5- .. —.C.
Electricians License No.85b -,7E
Other Trade's License No.
1. Location of land on which proposed work will be done:
,S'7c?5T /7.5//y .ex) 73' Z)
House Number Street :` Hamlet c
County Tax Map No 1000 Section ‘‘ Block 02 Lot ,`�
Subdivision Filed Map No. Lot
2 State existing use and occupancy of premises and intended use and occupancy of proposed construction.
a. Existing use and occupancy /Aa
b Intended use and occupancy
3. Nature of work(check which applicable): New Building Addition Alteration
Repair Removal Demolition Other Work �Ml4/6.7 .4, P
(Description)
4. Estimated Cost#02,sZ:ed Fee
(To be paid on filing this application)
5. If dwelling,number of dwelling units ` Number of dwelling units on each floor
If garage, number of cars /
6. If business,commercial or mixed occupancy, specify nature and extent of each type of use.
7. Dimensions of existing structures, if any: Front Rear Depth
Height Number of Stories
Dimensions of same structure with alterations or additions: Front Rear
Depth Height Number of Stories
8. Dimensions of entire new construction: Front Rear Depth
Height Number of Stories
9. Size of lot: Front Rear Depth
10. Date of Purchase Name of Former Owner
11. Zone or use district in which premises are situated
12. Does proposed construction violate any zoning law, ordinance or regulation?YES NOX
13 Will lot be re-graded? YES NO,<Will excess fill be removed from premises? YES NQx
14. Names of Owner of premises-- WA//1.9. 2 Addresses /J�'4'A Phone No...52g—c-f/g—
Name of Architect Address Phone No
Name of Contractor-Pcx�re-Ly',Vecz5:72GS Address ANN% .- /4z Phone No.g3/—7
15 a. Is this property within 100 feet of a tidal wetland or a freshwater wetland? *YES NO)(
* IF YES, SOUTHOLD TOWN TRUSTEES &D.E C. PERMITS MAY BE REQUIRED
b. Is this property within 300 feet of a tidal wetland? * YES NO X
* IF YES,D.E.C. PERMITS MAY BE REQUIRED
16 Provide survey,to scale,with accurate foundation plan and distances to property lines.
17. If elevation at any point on property is at 10 feet or below,must provide topographical data on survey.
18. Are there any covenants and restrictions with respect to this property? * YES NO)(
* IF YES,PROVIDE A COPY.
STATE OF NEW YORK)
SS.
COUNTY OF )
/7/Z7/7 9. , 5 143 7 being duly sworn,deposes and says that(s)he is the applicant
(Name of individual signing contract)above named,
(S)He is the " -/,?�7-
(Contractor,Agent,Corporate Officer,etc.)
of said owner or owners,and is duly authorized to perform or have performed the said work and to make and file this application;
that all statements contained m this application are true to the best of his knowledge and belief;and that the work will be
performed in the manner set forth in the application filed therewith.
Sworn to before me '1,
*1 day of=11MU' • I • E
Notar Public-State of New Yotft —
4303510
No .:, pmp Q118lltled In buttOlk County Signature of Applicant
rvry�timmission Expires May 12,2018
__. wr_.�-...�._..fir_ '1,.._••.
1800 01 51 40 p.m 12-01-2015 1 /1
•
cx -; o0 <0 `�
Town Hell Anni
54375 Main lid ; Telephone(631)765-1802
•
• ` r (631)76 3
P.O.Boz 1179 ;� ��1�? roper rich@ cfRi U o .nv.us ,
Southold,NY 11971-0959 _ �
• BUILDING DEPARTMENT
TOWN OP SOUTHOLD
APPLICATION FOR ELECTRICAL INSPECTION
• . REQUESTED BY: /7/ ,/./,,,.. ../4.--.4 .,,,,//e" Date:A: A5
Company Name: A4,A7�f 1G.z.ic
• Name: .5'r-/�iYb .• •
License No.: �a/7
Address: )44 --,"2a , P --4,/i2 V,-��///7 .
Phone No.: - • f v-7/5-... ,7c,2 �%'
JOBSITE INFORMATION: (*Indicates required information) -
*Name: S��,Z9, ,��iY� -
*Address: -57 - -ie ,.5 -
*Cross Street
•
*Phone No.: ' -nzF., 6'Q,5-•S- .
Permit No.: 39957 • .
Tax•Map District: 1000 Section: Block: 02 Lot: 5
*BRIEF DESCRIPTION OF WORK(Please Print Clearly) • C.y� r
•
(Please Circle Ali That Apply) ,
Is Job ready for inspection: cp I NO Rough In
*bayou need a TempCertificate: �1
*Do
Y a/ NO - -
Temp Information(if needed)
*Service Size: 1 Phase 3Phase 100 150 200 300 350 400 Other
*New Service: Re-connect Underground Number of Meters Change of Service Overhead
Additional Information: PAYMENT DUE WITH APPLICATION
,_____g..n k t_ / .-
82-Request for Inspection Form \
SURVEYOF LOT 2
- - - - MINOR SUBDIVISION
FOR N. CHARLES
pELUGA
flt? N SUFFOLK OCX/ TY,Kr
44--( **6gowenv al-20-2004\ aux caMT You(•
8 1000-66-3aS
1411;41 .,-
(. \�4. • 471 ,1 ,�+, �_
40 ` ' •. is= 48KW NG Kohler 5'
-:c..0-- off house
`'\i '�-
\ilk
orss t
4,11 %,
d►� .. ,.....% 3 . ]VA'9* \sik, „......
r=1 teary . Q
• ,. A
•
r,.
�q
.. .,_....... ..„...
• ,
. .. .
,... ,.....
•\
- • l -
anusoe - ---
Electrical Meter to
\%v • r • the right of the gas
oma• •,� `., • - .:;..._.. ,y--.. ._L: meter.
•.–.r,;--: ..– 7,.,,., —j.-_rgettegra----=
+ •
Lot
• "'Z rtq'
r \
w
•F:�
Gas Meter
,1 ) .' \
,�•ea000 as ts• ,•�• - .. JOHN C.EIHLERS LAND SURVEYOR
AM }�,_ ae�areunia«r KY.&�Na93102
61041141C SCALE . • YlV ,N.Y.MR
•
o- -
1 RETAIN ST9' Vl WATER RUNOFF OCCUPANCY OR
PUOFf ^
T TO THE TOWN CODE.TER 236 USE IS UNLAWFUL
WITHOUT CERTIFICATE
APPROVED AS NOT q7,7-7 OCCUPANCY
/
DATE: � I�/II8.P.# � /1,�
FEE: MO L
BY: � 2
NOTIFY BUILDING DEPARTMENT AT
765-1802 8 AM TO 4 PM FOR THE
FOLLOWING INSPECTIONS:
1. FOUNDATION - TWO REQUIRED
FOR POURED CONCRETE
2. ROUGH - FRAMING & PLUMBING
3. INSULATION
4. FINAL - CONSTRUCTION MUST
BE COMPLETE FOR C.O.
ALL CONSTRUCTION SHALL MEET THE
REQUIREMENTS OF THE CODES OF NEW
YORK STATE. NOT RESPONSIBLE FOR
DESIGN OR CONSTRUCTION ERRORS.
COMPLY WITH ALL CODES OF
NEW YORK STATE & TOWN CODES
AS REQUIRED AND CONDITIONS OF
-SOIItAA
I i
ELECTRICAL
INSPECTION REQUIRED
J
C ,
P ? - 6...r.fir
Model: 48RCL
KOHLER. Power Systems multi-Fuel
LPG/Natural
Gas
09001 Standard Features
Ems METSYSTEMS s • Kohler Co.provides one-source-responsibility for the
NATIONALLY REGISTERED generating system and accessories.
• The generator set and its components are prototype-tested,
f ":-!:" '`,.': '-."--Y.:'- '''''''"7"---_ _ -a_6=f- factory-built,and production-tested.
,i,,,-,j;1','1,-..., .. _ _ • The generator set accepts rated load in one step.
.' , ,k1•",1.".,k-'1- •••wL�; a' �+ : . '„,r_ _ • A standard five-year limited warranty covers all systems and
t ?. ;.;A:";,:11.4.0-1. t ? �a� 3,k, `=_=_ components.
Y• �0. 1.."0,1'=.:-.T1,.,.",... ;',/41r:
Jh * .� • Quick-ship(QS) models with selected features are available.
yt � **e:'= See your Kohler distributor for details.
S a ,� z," 4' �, i' a • RDC2 Controller
4 k.,& 5'��x ,, 'a T 4 -..---..----..---t--,_.---,:"."5:::" o One digital controller manages both the generator set and
a 't$, ” . ;
t.
="-• -
Alternator Specifications
Speccations Alternator
• The unique Fast-Response'" X excitation system delivers
'Manufacturer Kohler excellent voltage response and short-circuit capability using a
Type 4-Pole,Rotating Field rare-earth,permanent magnet(PM)-excited alternator.
Exciter type Brushless,Rare-Earth • Brushless,rotating-field alternator.
Permanent Magnet • NEMA MG1, IEEE,and ANSI standards compliance for
Leads:quantity,type temperature rise and motor starting.
4Q7BX 4,120/240
4P7BX 12,Reconnectable • Sustained short-circuit current of up to 300%of the rated
Voltage regulator Sotd State,Volts/Hz current for up to 10 seconds.
Insulation: NEMA MG1 • Sustained short-circuit current enabling downstream circuit
Material Class H breakers to trip without collapsing the alternator field.
Temperature rise 130°C,Standby
Bearing:quantity,type 1,Sealed • Self-ventilated and dripproof construction.
Coupling Flexible Disc
Amortisseur windings Full • Windings are vacuum-impregnated with epoxy varnish for
Voltage regulation,no-load to full-load ±1.0%RMS dependability and long life.
Unbalanced load capability 100%of Rated Standby • Superior voltage waveform from a two-thirds pitch stator and
Current skewed rotor.
One-step load acceptance 100%of Rating • Total harmonic distortion(THD)from no load to full load with
Peak motor starting kVA: (35%dip for voltages below) a linear load is less than 4%.
480 V,400 V 4P7BX(12 lead) 180(60 Hz),136(50 Hz)
240 V 4Q7BX(4 lead) 113(60 Hz)
Application Data
Engine Exhaust
Engine Specifications 60 Hz 50 Hz Exhaust System 60 Hz 50 Hz
Manufacturer General Motors Exhaust manifold type Dry
Engine:model,type Industrial Powertrain Exhaust flow at rated kW,m3/min.(cfm) 13.3(468) 10.6(375)
Vortec 5.0 L,4-Cycle Exhaust temperature at rated kW,dry
Natural Aspiration exhaust,°C(°F) 716(1320)
Cylinder arrangement V-8 Maximum allowable back pressure,
Displacement,L(cu.in.) 5.0(305) kPa(in.Hg) 10.2(3.0)
Bore and stroke,mm(in.) 94.9 x 88.4(3.74 x 3.48) Exhaust outlet size at engine hookup,
Compression ratio 9.4:1 mm(in.) 63(2.5)OD
Main bearings: quantity,type 5,M400 Copper Lead
Rated rpm 1800 1500 Fuel
Max.power at rated rpm,kW(HP) 66.4(89) 54.5(73) Fuel System
Piston speed,m/min.(ft./min.) 318(1044) 265(870)
Cylinder head material Cast Iron Fuel type LP Gas or Natural Gas
Piston type and material High Silicon Aluminum Fuel supply line inlet 1 in.NPT
Crankshaft material Nodular Iron Natural gas fuel supply pressure,kPa
Valve(exhaust)material Forged Steel (in.H2O) 1.74-2.74(7-11)
Governor type Electronic LPG vapor withdrawal fuel supply
Frequency regulation,no-load to pressure,kPa(in.H2O) 1.24-2.74(5-11)
full-load Isochronous Fuel Composition Limits* Nat.Gas LP Gas
Frequency regulation,steady state ±1.0% Methane,%by volume 90 min. —
Frequency Fixed Ethane,%by volume 4.0 max. —
Air cleaner type Dry Propane,%by volume 1.0 max. 85 min.
Propene,%by volume 0.1 max. 5.0 max.
Engine Electrical C4 and higher,%by volume 0.3 max. 2.5 max.
Engine Electrical System Sulfur,ppm mass 25 max.
Ignition system Electronic Lower heating value,
- MJ/m3(Btu/k3),min. 33.2(890) 84.2(2260)
Battery charging alternator:
Ground(negative/positive) Negative * Fuels with other compositions may be acceptable..If your fuel is
Volts(DC) 12 outside the listed specifications,contact your local distributor for
Ampere rating 70 further analysis and advice. ,
Starter motor rated voltage(DC) 12 Lubrication
Battery,recommended cold cranking
amps(CCA): Lubricating System
Qty.,rating for-18°C(0°F) One,630 Type Full Pressure
Battery voltage(DC) 12 Oil pan capacity,L(qt.) 4.3(4.5)
Battery group size 24 Oil pan capacity with filter,L(qt.) 4 7(5.0)
Oil fitter quantity,type 1,Cartridge
G4-211 (48RCL) 7/14e
• ,,
Application Data
Cooling RDC2 Controller
Radiator System 60 Hz 50 Hz or___----
Ambient temperature,°C(°F) 45(113) MsisrEms
Radiator system capacity,including
engine,L(gal.) 17(4.5) %taxa 240 0
Hz
Engine water flow,Lpm m 117.3(31) 98.4 26 �a eo.°
9 jacketP (gpm) ( ) ® 2 a
Heat rejected to cooling water at rated NO
kW,dry exhaust,kW(Btu/min.) 48.4(2750) 42.9(2440) 'v ���
Water pump type Centrifugal
rv. aum aui
Fan diameter,mm(in.) qty.3 @ 408(16) �t0 y i o o
Fan power requirements(powered by
engine battery charging alternator) 12VDC,18 amps each
The RDC2 controller provides integrated control for the
Operation Requirements generator set, Kohler®Model RXT transfer switch,
Air Requirements 60 Hz 50 Hz programmable interface module(PIM),and load control
Radiator-cooled cooling air, module(LCM).
m3/min.(scfm)t 51 (1800) 51 (1800)
Combustion air,m3/min.(cfm) 4.5(159) 3.7(132) The RDC2 controller's 2-line LCD screen displays status
Air over engine,m3/min.(cfm) 25(900) 25(900) messages and system settings that are clear and easy to read,
# Air density=1.20 kg/m3(0.075 Ibm/ft3) even in direct sunlight or low light. .
Fuel Consumption$ RDC2 Controller Features
Natural Gas,m3/hr.(cfh)at%load 60 Hz 50 Hz • Membrane keypad:
100% 19.8 (699) 15.8 (559) o OFF,AUTO,and RUN pushbuttons
75% 16.9 (598) 13.5 (478) o Select and arrow buttons for access to system
50% 13.0 (461) 10.4 (368) configuration and adjustment menus
25% 9.1 (321) 7.3 (257) • LED indicators for OFF,AUTO,and RUN modes
Exercise 4.2 (147) 4.2 (147)
LP Gas,m3/hr.(cfh)at%load 60 Hz 50 Hz • LED indicators for utility power and generator set source
283 6.4 (226) availability and ATS position(Model RXT transfer switch
100% 8.0
(283) required)
75% 6.7 (235) 5.3 (188)
50% 5.0 (175) 4.0 (140) • LCD screen:
25% 3.4 (121) 2.7 (97) o Two lines x 16 characters per line
Exercise 1.5 (54) 1.5 (54) o Backlit display with adjustable contrast for excellent
# Nominal Fuel Rating: Natural gas,37 MJ/m3(1000 Btu/ft) visibility in all lighting conditions
LP Vapor,93 MJ/m3(2500 Btu/ft3) • Scrolling system status display
LP vapor conversion factors: o Generator set status
8.58 ft.3=1 lb. o Voltage and frequency
0.535 m3=1 kg. o Engine temperature
36.39 ft.3=1 gal. o Oil pressure
o Battery voltage
Sound Enclosure Features o Engine runtime hours
• Sound-attenuating enclosure uses acoustic insulation that • Date and time displays
meets UL 94 HF1 flammability classification and repels • Smart engine cooldown senses engine temperature
moisture absorption. • Digital isochronous governor to maintain steady-state speed
• Internally mounted critical silencer. at all loads
• Skid-mounted,aluminum construction with two removable • Digital voltage regulation: ±1.0%RMS no-load to full-load
access panels. • Automatic start with programmed cranking cycle
• Fade-,scratch-,and corrosion-resistant Kohler®cashmere • Programmable exerciser can be set to start automatically on
powder-baked finish. any any future day and time,and to run every week or every
Sound Data two weeks
Model 48RCL 8 point logarithmic average sound levels are • Exercise modes
58 dB(A)during weekly engine exercise and 61 dB(A)during o Unloaded exercise with complete system diagnostics
full-speed generator diagnostics and normal operation. The o Unloaded full-speed exercise
lowest point sound levels are 56 dB(A)and 60 dB(A) o Loaded full-speed exercise(Model RXT ATS required)
respectively as compared to competitor ratings.* • Front-access mini USB connector for SiteTech' connection
All sound levels are measured at 7 meters with no load. • Integral Ethernet connector for Kohlere OnCue®
• Lowest of 8 points measured around the generator. Sound levels at other points • Built-in 2.5 amp battery charger
around generator may be higher depending on installation parameters. • Remote two-wire start/stop capability for optional connection
of Model RDT or RSB transfer switches
See additional controller features on the next page.
04-211 (48RCL) 7/14e
Cr
KOHLER CO.,Kohler,Wisconsin 53044 USA Kohler Power Systems
Phone 920-457-4441,Fax 920-459-1646 Asia Pacific Headquarters
For the nearest sales and service outlet in the 7 Jurong Pier Road
US and Canada,phone 1-800-544-2444 Singapore 619159
KOHLERPower.com Phone(65)6264-6422,Fax(65)6264-6455
Additional RDC2 Controller Features Electrical System
• Diagnostic messages ❑ Battery
o Displays diagnostic messages for the engine,generator, ❑ Battery Heater
Model RXT transfer switch,programmable interface StartingAids
module(PIM),and load control module(LCM)
0 Block Heater
o Over 70 diagnostic messages can be displayed [recommended for ambient temperatures below 0°C(32°F)]
• Maintenance reminders Controller Accessories
• System settings ❑ Programmable Interface Module(PIM)
o System voltage,frequency,and phase (provides 2 digital inputs and 6 relay outputs)
o Voltage adjustment ❑ Load Control Module(LCM)
o Measurement system,English or metric (provides 4 power relays and 2 HVAC relays)
• ATS status(Model RXT ATS required) Transfer Switch
o Source availability 0 Model RXT Automatic Transfer Switch(see G11-121)
o ATS position(normal/utility or emergency/generator) ❑ Model RDT Automatic Transfer Switch(see G11-98)
o Source voltage and frequency ❑ Model RSB Automatic Transfer Switch(see G11-101)
• ATS control(Model RXT ATS required) Miscellaneous
o Source voltage and frequency settings ❑ Rated Power Factor Testing
o Engine start time delay Literature
o Transfer time delays ❑ General Maintenance Literature Kit
o Fixed pickup and dropout settings ❑ Overhaul Literature Kit
o Voltage calibration ❑ Production Literature Kit
• Programmable Interface Module(PIM) status displays Other Options
o Input status(active/inactive) ❑
o Output status(active/inactive) ❑
• Load control module(LCM)menus 0
o Load status
o Test function Dimensions and Weights
Generator Set Standard Features Overall Size,Lx W x H,mm(in.): 2280 x 836 x 1147
(89.8 x 32.9 x 45.2)
• Aluminum sound enclosure with enclosed silencer Shipping Weight,wet,kg(lb.). 862(1900)
• Battery rack and cables
• Electronic,isochronousgovernor Weight includes generator set with engine fluids and 4Q10X alternator,
sound enclosure,and silencer.
• Flexible fuel line
• Gas fuel system (includes fuel mixer,electronic secondary
gas regulator,two gas solenoid valves,and flexible fuel line
between the engine and the skid-mounted fuel system
components)
• Integral vibration isolation H
• Line circuit breaker
• Oil drain extension
• Operation and installation literature
• RDC2 controller with built-in battery charger w-01 L .)
• Standard five-year or 2000 hour limited warranty
NOTE:This drawing is provided for reference only and should not be
Available Options used for planning installation. Contact your local distributor for more
detailed information.
Approvals and Listings
❑ UL 2200 Listing(60 Hz only) DISTRIBUTED BY:
❑ CSA Approval(60 Hz only)
Communication Accessories
❑ OnCuee Plus Generator Management System for remote
monitoring(see specification sheet G6-140)
❑ OnCue•Plus Wireless Generator Management System for
remote monitoring(see specification sheet G6-137)
®2011,2012,2013,2014 by Kohler Co. All rights reserved.
G4-211 (411RCL) 7/14e
Gas Existing Gas
Meter Line into the
\ AZ home
0 1 1/2"
(XX') - I" Black Flexible
Pipe Gas Pipe
(XX')- I,'Plastic pipe i
buried with tracer line.
II\ Gas Company : X
Existing Gas Main Generator Gas
Shut off Valve
Roof Diagnostics Solar&Electric,LLC. John Marciano
Plumbing Riser Diagram 57856 Main Rd. Southold NY 11971
Generator Installation 48kW NG Stand-by Generator
Phone: 732.974.8874