Loading...
The URL can be used to link to this page
Your browser does not support the video tag.
Home
My WebLink
About
46272-Z
S�FfO& Town of Southold 9/17/2021 .t P.O.Box 1179 y x 53095 Main Rd 1 Southold,New York 11971 CERTIFICATE OF OCCUPANCY No: 42334 Date: 9/17/2021 THIS CERTIFIES that the building HVAC Location of Property: 10095 Route 25,Mattituck SCTM#: 473889 Sec/Block/Lot: 142.4-26 Subdivision: Filed Map No. Lot No. conforms substantially to the Application for Building Permit heretofore filed in this office dated 5/10/2021 pursuant to which Building Permit No. 46272 dated 5/19/2021 was issued, and conforms to all of the requirements of the applicable provisions of the law. The occupancy for which this certificate is issued is: Three(3)HVAC units to existing Walgreens store as applied for. The certificate is issued to Mattituck Plaza LLC of the aforesaid building. SUFFOLK COUNTY DEPARTMENT OF HEALTH APPROVAL ELECTRICAL CERTIFICATE NO. 46272 9/13/2021 PLUMBERS CERTIFICATION DATED th rize ignature o�SUFFot,��o TOWN OF SOUTHOLD aye BUILDING DEPARTMENT y x TOWN CLERK'S OFFICE oy • SOUTHOLD, NY dol � Sao BUILDING PERMIT (THIS PERMIT MUST BE KEPT ON THE PREMISES WITH ONE SET OF APPROVED PLANS AND SPECIFICATIONS UNTIL FULL COMPLETION OF THE WORK AUTHORIZED) Permit#: 46272 Date: 5/19/2021 Permission is hereby granted to: Mattituck Plaza LLC PO BOX 77 Mattituck, NY 11952 To: Install (3) new HVAC units to existing Walgreens store as applied for. At premises located at: 10095 Route 25, Mattituck SCTM #473889 Sec/Block/Lot# 142.-1-26 Pursuant to application dated 5/10/2021 and approved by the Building Inspector. To expire on 11/18/2022. Fees: CO-COMMERCIAL $50.00 ACCESSORY $250.00 ELECTRIC $125.00 Total: $425.00 Building Inspector ®��OF SOU��®� Town Hall Annex ® Telephone(631)765-1802 54375 Main Road Fax(631)765-9502 P.O.Box 1179 ® sean.deviine-town.southold.ny.us Southold,NY 11971-0959 �` a BUILDING DEPARTMENT TOWN OF SOUTHOLD CERTIFICATE OF ELECTRICAL COMPLIANCE SITE LOCATION Issued To: Mattituck Plaza LLC Address: 10095 Route 25 city-Mattituck st: NY ### 11952 Building Permit#: 46272 section: 142 Block: 1 Lot: 26 WAS EXAMINED AND FOUND TO BE IN COMPLIANCE WITH THE NATIONAL ELECTRIC CODE Contractor: DBA: Borrelli Electric Corp License No: 31320ME SITE DETAILS Office Use Only Residential Indoor X Basement Service Commerical X Outdoor X 1st Floor Pool New X Renovation 2nd Floor Hot Tub Addition Survey X Roof X Garage INVENTORY Service 1 ph Heat Duplec Recpt Ceiling Fixtures Bath Exhaust Fan Service 3 ph Hot Water GFCI Recpt Wall Fixtures Smoke Detectors Main Panel A/C Condenser Single Recpt Recessed Fixtures CO2 Detectors Sub Panel A/C Blower Range Recpt Ceiling Fan Combo Smoke/CO Transformer UC Lights Dryer Recpt Emergency Fixtures Time Clocks Disconnect 2 Switches 4'LED Exit Fixtures 11 Pump Other Equipment: (2) York 5 Ton R-41 OA Air-conditioners Notes: AC' s On Roof Inspector Signature: (�- Date: September 13, 2021 S. Devlin-Cert Electrical Compliance Form �uFFpL� BUILDING DEPARTMENT- Electrical Inspector ®� COGS TOWN OF SOUTHOLD w Town Hall Annex.- 54375 Main Road - PO Box 1179 Southold, New York 11971-0959 Telephone (631) 765-1802 - FAX (631) 765-9502 l . c rogerr(cb-southoldtownny.gov - seandasoutholdtownny.gov APPLICATION FOR ELECTRICAL INSPECTION ELECTRICIAN INFORMATION (All Information Required) Date: 2021 Company Name: RAd,% El &9P Name: j License No.: email: 0 Phone No: (p- -(#0I E0'request an email copy of Certificate of Compliance Address.: ,(d bk E k& lon NY ( JOB SITE INFORMATION (All information Required) Name: Address: ��., 2 `i6e My I L Cross Street: Phone No.: - Bldg.Permit#: email: No Tax Map District: 1000 Section: � 'Z,. Block: Lot: BRIEF DESCRIPTION OF WORK (Please Print Clearly) �n 3 - Check AII.That Apply: Is job ready for inspection?: ❑YES Er [—]Rough In ❑Final Do you need a Temp Certificate?: ❑YES Issued On Temp Information: (All information required) Service Size -13❑4 Ph 3 Ph Size: A # Meters Old Meter# ❑New Service ❑ Service Reconnect ❑ Underground [—]Overhead # Underground Laterals 01 ❑2 ❑H Frame❑Pole Work done on Service? ❑Y ❑N Additional Information: .LX ��Curiv�e� Xc5 � �, cc. eyed trs PAYMENT DUE WITH APPLICATION Electrical Inspection Form 2020.xlsx hO��pFS0UTy0� q4 271, * # TOWN OF SOUTHOLD BUILDING DEPT. �ycou765.1802 INSPECTION [ ] FOUNDATION 1 ST [ ] ROUGH PL13G. [ =] FOUNDATION 2ND. [ ] INSULATIOWCAULKING [ ] FRAMING /STRAPPING [ ] FINAL [ ] FIREPLACE& CHIMNEY [ ]- FIRE SAFETY INSPECTION [ ] FIRE RESISTANT CONSTRUCTION [ ] FIRE RESISTANT PENETRATION [ ] ELECTRICAL (ROUGH) % r ELECTRICAL-(FINAL) [ ] CODE VIOLATION [/ ] PRE C/O REMARKS: ON 'fin, DATE INSPECTOR a0E SOU,y Wu 146 f !V # # TOWN OF-'SOUTFIOLD BUILDING DEPT. 765-1802 INSPECTION [ ] FOUNDATION 1ST [ ] ROUGH PL13G. [ ] FOUNDATION 2ND J,, ] INSULATION/CAULKING [ ] FRAMING/STRAPPING [ ] FINAL [ ] FIREPLACE & CHIMNEY [ ] FIRE SAFETY`INSPECTION [ ] FIRE RESISTANT CONSTRUCTION [ ] FIRE RESISTANT PENETRATION :[ ] ELECTRICAL (ROUGH) M,EL- ECTRICAL (FINAL) [ ] CODE VIOLATION [ " ] PRE C/O REMARKS: DATE =Z INSPECTOR ° of soulyo� l 6 2-7 2— * # TOWN OF -SOUTHOLD BUILDING DEPT. 765■1802 f INSPECTION [ ] FOUNDATION 1ST [ ] ROUGH PLBG. [ ] FOUNDATION 2ND [ ] -INSULATIOWCAULKING- - [ ] FRAMING /STRAPPING [ ] FINAL [ ,] FIREPLACE & CHIMNEY [ ] FIRE SAFETY INSPECTION" [ ] FIRE RESISTANT CONSTRUCTION [ ] FIRE RESISTANT PENETRATION = [ ] ELECTRICAL (ROUGH) ELECTRICAL (FINAL) [ ] CODE VIOLATION [ ] PRE C/O REMARKS: 2 Ac-, S- G �j Trod <� DATE INSPECTOR �-- FIELD INSPECTION REPORT DATE COMMENTS FOUNDATION(IST) H ----------------------------------- FOUNDATION (2ND) ROUGH FRAMING& PLUMBING C7 y INSULATION PER N.Y. y (� STATE ENERGY CODE J n FINAL ADDITIONAL GQ1VI,1VIENTS . _ -w loo -cab aa-LA -PA I M ele,ciL0 rl, G z X 0 z T 0 WN 0 F,150 t A-I I(,)1,1)— R I i'j 1,t)1, NG DEIIARTMENIT� 0i gar 1 WI Aunex 54375 Maiii Road P. Oa fic),N1179,Soutimid, iNIV 11971-0,54 VlOte I'dephona(63 1) 0-!15 FaQi fi 5-9,02, 1 Mile fluwovud APPUCAT'i"ION HOiR, SURALDING PEE"I't'I'VI I Far Gfjr4,Uu,;Ialv PUMT NO, h2J R- Br-OA M ITT I t�IA?j r MAY 1 0 2021 -APPOCAA10406006trros mutftfikd out i -khe' owner,an .-DaIf4:,AprjI '30, 421 :O`W,N�giSl Of PROI�WTY.- t�Ame:,Msttltuc.k-Plaza LLC SCT a 142000100026000 ProjectAd,dress,jQ095 RoUt e ,25, Mattituck NY 11952 'hane#:631-298-84914 MailblgAd6essl GG95,Route' 25. Unit 4, Tlvqatfl�uck NY X952 CONTACT PFRSdX.- P4,fe-00seph D'Albora M a 1;1 i n g,A d d ressr 11 11 ROUte 110, -$Oite 353, IF-armingdale-, NY 117',15 pharlF 9:9 17-577-5869 Lrnafl:' Joe@dansonhei,q'htsf.,0ITt INFORNIATI ON, N Mailing A ftiejs, Phonv Email.- CONTRACTbRINFOAMATIO, Name--Only 111',Ne.w York rAChaniCal LLC Mining Addres,-.,- 1 1 -Route 110',Suite 353, Farmingdale, NY 1173.5 �neu IT-,631-274-7002' OESCRIPTION G�,PROP6seb CONSTIWMON" DjWwSiructury OAddition ClAfteratikirk DPS',,pIa4 -10[lamb1fdon Lstfrnated CUSt 0f, PT0fr,,M WRI the licat bt,rie-g;aded? 0'dei R,Nit, VVI)i QxCess fill e removed from promIsLis? Perpj'R,6tail/Pharmacy 7�ne k)r,jj3 d triGt In "Which pre igen i,�t �t��l: � , �� i tl e any wvenants zftcl restr-icdont,with respect tai <;ri0"4 t k,. M ='. ��t�i alp.� s� i�fas;nll d�sifk�;r•;�s�eyed aCr :�y"v�txr iae:,s as��re�rtdect�y - ',Chiapt0r,136o thea' 14iri ids-AWL i l Jt2t , HE 1;8t 4+ i Cidklr iiililrr�'iae r37priY'far't � suer .c,� 47 � 'P. Ftr t't r irurri'se Ehcf ti(>ilri bus siapp , ep= tsr f r lF sl'd�Sutf ffc,°t�cn ;PJB'r*�4i �hrlra? + ;iaL ur ` R iinar dst f it yrt ty �t � icy �f nilitirsr�s;albiliscCxrr rpt. y`„ spi+�riiufen�stbti�. as hei� rsi :Tt:�?;:5tip�l':�5i:3-d+ra to s"srrijsty znri life tvx + rcSinati,:, ,f: sr - .« hs ysPir r i� :ari 4ir�ular q ;Cry ni truth as��info en Frgtr �r� t tiilttt g,tts r rr�s y;in* ecc io rs: �Is� t rs r4t'fr � rit ark : n ghat ri ;C7r► ,;,'ir ir7e n ru'r as nt lar ,AS-f'4 AppScaitieon- U4MJtt d By(pr[rat a jG� 'sepnr QAvtfio 'zed' g,�nt Date,. S ST. COUP OF—fAj-,µax'v--) , I - (Name of in ividu*11 sign rid con,L tt)obove narned,, the,zipp (Qirltrac�6,Ag6rit,,6rproraLL-Off of said ra ne,r or ownew s,a nd 1�dlily authortz"to perform-or have pp,'rforpip� d tI-te 5@1d�voA,,Arad 10 rajah anti file this c�` i t Lit i�, tailaG t r e 4 .t i i�in tl� u l r ticr r tr f Lhebesto his/her ra" 1' and ;� ai , d i,the�or�;WWl'V p,,pkrf,6rrnE-d in thy! rhannw set fQrt� in ttt�applis,�tio file'�I�r�a��3tlt. Swbfln before me this, pf Not arte Public Commonwealth of Pennsylvania-Notary Seal Theresa A.Halliday,Notary Public Wayne County My commission expiresApril 29, �• aAasf Commission number 1198769 ,e.ret e Opp fcan.t=is not tile oWnerj Member,Pennsylvania Association of Notaries 4-J�aj TiLptidirtg at ,l ah . f ti,r�ri� a ply on ray ehalf to fig i of kh f � �:aa Cay �'for apprapjs described hbrL-in. i � Print Owrie s,t ar' BUILDING DEPARTMENT-Electrical Inspector TOWN OF SOUTHOLD Town Hall Annex- 54375 Main Road - PO Box 1179 Southold, New York 11971-0959 Telephone (631) 765-1802 - FAX (631) 765-9502 rogerr@southoldtownny.gov - seand@southoldtownny.gov APPLICATION FOR ELECTRICAL INSPECTION ELECTRICIAN INFORMATION (All information Required) Date: �j 2021 Company Name: . I EiQ Name: t's w, License No.: .31320 - UI- email: Phone No:S to• -(AOI 4 [a1'request an email copy of Certificate of Compliance Address.: d bj,6*, iE WC,%--fir N irloq JOB SITE INFORMATION (All Information Required) Name: `I IQ� Address: fie.. Z ``0°�t�. Cross Street: Phone No.: (,p ( - QTf vgAgg Bldg.Permit#: email: ' p�, c SDY1l�ICi Tax Map District: 1000 Section: ��'Z,. Block: Lot: BRIEF DESCRIPTION OF WORK (Please Print Clearly) 'QUbNh 3 1 '41 Check All That Apply: Is job ready for inspection?: ❑YESN ❑Rough In ❑Final Do you need a Temp Certificate?: ❑YES9 O Issued On Temp Information: (All information required) Service Size ❑1 Ph ❑3 Ph Size: A # Meters Old Meter# ❑New Service ❑ Service Reconnect ❑ Underground ❑Overhead # Underground Laterals ❑1 ❑2 ❑H Frame❑Pole Work done on Service? ❑Y ❑N Additional Information: e-etr5 PAYMENT DUE WITH APPLICATION Electrical Inspection Form 2020.xlsx Suffolk County Dept.of Labor,Licensing&Consumer Affairs e � MASTER PLUMBING —� Name JOSEPH D'ALBORA Business Name This certifies that the bearer is duly licensed ONLY IN NEW YORK MECHANICAL LLC by the County of suffolk License Number:MP-51771 Rosalie Drago Issued: 06/03/2013 Commissioner Expires: 06/01/2022 DANSHEI-03 VPETRUNGARO ACO�Q° CERTIFICATE OF LIABILITY INSURANCE DATE(MMIDDIYYYY)x/29/2021 THIS CERTIFICATE IS ISSUED AS A MATTER OF INFORMATION ONLY AND CONFERS NO RIGHTS UPON THE CERTIFICATE HOLDER.THIS CERTIFICATE DOES NOT AFFIRMATIVELY OR NEGATIVELY AMEND, EXTEND OR ALTER THE COVERAGE AFFORDED BY THE POLICIES BELOW. THIS CERTIFICATE OF INSURANCE DOES NOT CONSTITUTE A CONTRACT BETWEEN THE ISSUING INSURER(S),AUTHORIZED REPRESENTATIVE OR PRODUCER,AND THE CERTIFICATE HOLDER. IMPORTANT: If the certificate holder is an ADDITIONAL INSURED,the policy(ies)must have ADDITIONAL INSURED provisions or be endorsed. If SUBROGATION IS WAIVED, subject to the terms and conditions of the policy,certain policies may require an endorsement. A statement on this certificate does not confer rights to the certificate holder in lieu of such endorsement(s). PRODUCER CONTACT J.W.Hirschfeld Agency,Inc. PHONE 631 421-2525 FAX 631 421-3015 326 New York Ave (A/C,No,Ext):( ) (A/C,No).(631) Huntington,NY 11743 �UDREss info@jwhinsurance.com INSURER(S)AFFORDING COVERAGE NAIC# INSURER A.Merchants Preferred Insurance Company 112901 INSURED INSURER B. Only In New York Mechanical LLC INSURER C. 1111 Route 110 Unit 353 INSURER D. Farmingdale,NY 11735 INSURER E INSURER F. COVERAGES CERTIFICATE NUMBER: REVISION NUMBER: THIS IS TO CERTIFY THAT THE POLICIES OF INSURANCE LISTED BELOW HAVE BEEN ISSUED TO THE INSURED NAMED ABOVE FOR THE POLICY PERIOD INDICATED. NOTWITHSTANDING ANY REQUIREMENT, TERM OR CONDITION OF ANY CONTRACT OR OTHER DOCUMENT WITH RESPECT TO WHICH THIS CERTIFICATE MAY BE ISSUED OR MAY PERTAIN, THE INSURANCE AFFORDED BY THE POLICIES DESCRIBED HEREIN IS SUBJECT TO ALL THE TERMS, EXCLUSIONS AND CONDITIONS OF SUCH POLICIES.LIMITS SHOWN MAY HAVE BEEN REDUCED BY PAID CLAIMS. IN RI ADDL SUBR POLICY EFF POLICY EXP LTR TYPE OF INSURANCE IND WVD POLICY NUMBER (MDD MM DD LIMITS A X COMMERCIAL GENERAL LIABILITY EACH OCCURRENCE $ 2,000,000 CLAIMS-MADE OCCUR CTRIO03449 1/21/2021 1/21/2022 DAMAGE TO RENTED —_500,000 PREMISES(Ea occurrence) $ _ MED EXP(Any oneperson) $ 5,000 PERSONAL&ADV INJURY $ 2,000,000 GEN'L AGGREGATE LIMIT APPLIES PER GENERAL AGGREGATE $ 4'000,000 X POLICY®JECOT- 17 LOC PRODUCTS-COMP/OP AGG $ 4,000,000 OTHER $ ACOMBINED SINGLE LIMIT AUTOMOBILE LIABILITY (Ea accident $ ANY AUTO BODILY INJURY Perperson) $ OWNED SCHEDULED AUTOS ONLY AUTOS BODILY INJURY Per accident $ HIRED NON OWNED PROPERTY DAMAGE AUTOS ONLY AUTOS ONLY Per accident $ $ i UMBRELLA LIAB []!CLAIMS-MADE CCUR EACH OCCURRENCE $ EXCESS LIAB AGGREGATE $ DED 1 ; RETENTION$ Is WORKERS COMPENSATION I PER I OTH- AND EMPLOYERS'LIABILITY Y/N __STATUTE__ ER __ _ ANY PROPRIETOR/PARTNER/EXECUTIVE j EL EACH ACCIDENT $ OFFICER/MEMBER EXCLUDED _J N/A —— (Mandatory in NH) EL DISEASE-EA EMPLOYEE $ _ If yes•describe under DESCRIPTION OF OPERATIONS below EL DISEASE-POLICY LIMIT $ DESCRIPTION OF OPERATIONS/LOCATIONS/VEHICLES (ACORD 101,Additional Remarks Schedule,may be attached if more space is required) hvac contractor CERTIFICATE HOLDER CANCELLATION SHOULD ANY OF THE ABOVE DESCRIBED POLICIES BE CANCELLED BEFORE Town of Southold THE EXPIRATION DATE THEREOF, NOTICE WILL BE DELIVERED IN ACCORDANCE WITH THE POLICY PROVISIONS. 54375 NY-25 Southold,NY 11971 AUTHORIZED REPRESENTATIVE ACORD 25(2016/03) ©1988-2015 ACORD CORPORATION. All rights reserved. The ACORD name and logo are registered marks of ACORD STATE OF NEW YORK WORKERS' COMPENSATION BOARD CERTIFICATE OF NYS WORKERS' COMPENSATION INSURANCE COVERAGE la.Legal Name&Address of Insured(Use street address only) lb.Business Telephone Number of Insured Only In New York Mechanical LLC 917-577-5869 1111 Route 110,Unit 353 lc.NYS Unemployment Insurance Employer Farmingdale,New York 11735 Registration Number of Insured Work Location of Insured (Only required if coverage is Id. Federal Employer Identification Number of Insured specifically limited to certain locations in New York State, i.e., a or Social Security Number Wrap-Up Policy) 844378044 2.Name and Address of the Entity Requesting Proof of 3a. Name of Insurance Carrier Coverage(Entity Being Listed as the Certificate Holder) Merchants Mutual Town of Southold 3b.Policy Number of entity listed in box"la" 54375 NY-25 WCA9103206 Southold, NY 11971 3c. Policy effective period 1-21-2021 to 1-21-2022 3d. The Proprietor,Partners or Executive Officers are ❑ included. (Only check box if all partners/officers included) X all excluded or certain partners/officers excluded. This certifies that the insurance carrier indicated above in box "Y' insures the business referenced above in box "la" for workers' compensation under the New York State Workers' Compensation Law. (To use this form, New York (NY) must be listed under Item 3A on the INFORMATION PAGE of the workers' compensation insurance policy). The Insurance Carrier or its licensed agent will send this Certificate of Insurance to the entity listed above as the certificate holder in box"T'. The Insurance Carrier will also notify the above certificate holder within 10 days IF a policy is canceled due to nonpayment of premiums or within 30 days IF there are reasons other than nonpayment of premiums that cancel the policy or eliminate the insured from the coverage indicated on this Cert fcate. (These notices may be sent by regular mail) Otherwise, this Certificate is valid for one year after this form is approved by the insurance carrier or its licensed agent, or until the policy expiration date listed in box "3c"; whichever is earlier. Please Note: Upon the cancellation of the workers' compensation policy indicated on this form, if the business continues to be named on a permit, license or contract issued by a certificate holder, the business must provide that certificate holder with a new Certificate of Workers' Compensation Coverage or other authorized proof that the business is complying with the mandatory coverage requirements of the New York State Workers' Compensation Law. Under penalty of perjury,I certify that I am an authorized representative or licensed agent of the insurance carrier referenced above and that the named insured has the coverage as depicted on this form. Approved by: Susan Hirschfeld Mohr (Print name of authorized representative or licensed agent of insurance carrier) Approved by: Sugaa .�bogfifgIeCiI . to& 4-29-2021 (Signature) (Date) Title: President Telephone Number of authorized representative or licensed agent of insurance carrier: 631-421-2525 Please Note: Only insurance carriers and their licensed agents are authorized to issue Form C-105.2 Insurance brokers are NOT authorized to issue it. C-105.2 (9-07) www.wcb.state.ny.us rnWR Workers' CERTIFICATE OF INSURANCE COVERAGE Yo TE Compensation Board DISABILITY AND PAID FAMILY LEAVE BENEFITS LAW PART 1.To be completed by Disability and Paid Family Leave Benefits Carrier or Licensed Insurance Agent of that Carrier 1 a.Legal Name&Address of Insured(use street address only) 1 b.Business Telephone Number of Insured ONLY IN NEW YORK MECHANICAL LLC 917-577-5869 1111 ROUTE 110, UNIT 353 FARMINGDALE,NY 11735 1c.Federal Employer Identification Number of Insured or Social Security Number Work Location of Insured(Only required if coverage is specifically limited to certain locations in New York State,i e.,Wrap-Up Policy) 844378044 2.Name and Address of Entity Requesting Proof of Coverage 3a. Name of Insurance Carrier (Entity Being Listed as the Certificate Holder) ShelterPoint Life Insurance Company Town of Southold 3b.Policy Number of Entity Listed in Box"l a" 54375 NY-25 DBL548748 Southold, NY 11971 3c.Policy effective period 01/21/2021 to 01/20/2022 4. Policy provides the following benefits 0 A. Both disability and paid family leave benefits. F1 B.Disability benefits only E] C.Paid family leave benefits only. 5. Policy covers. FXJ A.All of the employer's employees eligible under the NYS Disability and Paid Family Leave Benefits Law. M B.Only the following class or classes of employer's employees Under penalty of perjury,I certify that I am an authorized representative or licensed agent of the insurance carrier referenced above and that the named insured has NYS Disability and/or Paid Family Leave Benefits insurance coverage as described above Date Signed 4/29/2021 By AW (Signature of insurance carrier's authorized representative or NYS Licensed Insurance Agent of that insurance carrier) Telephone Number 516-829-8100 Name and Title Richard White, Chief Executive Officer IMPORTANT: If Boxes 4A and 5A are checked, and this form is signed by the insurance carrier's authorized representative or NYS Licensed Insurance Agent of that carrier, this certificate is COMPLETE. Mail it directly to the certificate holder. If Box 4B,4C or 5B Is checked, this certificate Is NOT COMPLETE for purposes of Section 220, Subd. 8 of the NYS Disability and Paid Family Leave Benefits Law. It must be mailed for completion to the Workers'Compensation Board, Plans Acceptance Unit, PO Box 5200, Binghamton, NY 13902-5200. PART 2.To be completed by the NYS Workers' Compensation Board (only if Box 4C or 56 of Part 1 has been checked) State of New York Workers' Compensation Board According to information maintained by the NYS Workers'Compensation Board,the above-named employer has complied with the NYS Disability and Paid Family Leave Benefits Law with respect to all of his/her employees. Date Signed By (Signature of Authorized NYS Workers'Compensation Board Employee) Telephone Number Name and Title Please Note:Only insurance carriers licensed to write NYS disability and paid family leave benefits insurance policies and NYS licensed insurance agents of those insurance careers are authonzed to issue Form DB-120.1.Insurance brokers are NOT authorized to issue this form. DB-120.1 (10-17) 111111111°°°1°°°°1°°11111°1!1111°°1111111111 K, „a SUBMITTAL DATA Order#: Date: 04/26/2021 Project: 19981 - Mattituck, NY Project #: Submitter: Travis Wolf UPG National Accounts-York 5005 York Drive., Norman, Oklahoma 73069 COMPLY WITH ALL CODES OF APPROVED AS NOT D NEW YORK STATE & TOWN CODES b��� AS REQUIRED AND CONDITIONS OF DATE: B.P.# SOUTHOLD TOWN ZBA FEE:49 'O&D-3Y: NOTIFY BUILDING DEPARTMENT AT SOUTHOLDTOWNPLANNING!'r 765-1802 8 AM TO 4 PM FOP THE SOUTHOLDTOWN TRUSTE �� FOLLOWING INSPECTIONS: N.Y.S.DEC 1. FOUNDATION - TWO REQUIRED FOR POURED CONCRETE 2. ROUGH - FRAMING & PLUMBING 3. INSULATION 4. FINAL - CONSTRUCTION MUST BE COMPLETE FOR C.O. ALL CONSTRUCTION SHALL MEET THE REQUIREMENTS OF THE CODES OF NEW It� YORK STATE. NOT RESPONSIBLE FOR DESIGN OR CONSTRUCTION ERRORS. OCCUPANCY OR USE IS UNLAWFUL WITHOUT CERTIFICATE F OCCUPANCY Information is subject to change without notice Check local codes Printed 04/26/2021 ` ONLY IN NEW YORKMECHANICAL- LLC TO: Attention: Building Department Town of Southold 54375 Main Road Re: Permit Application Packet Southold, NY 11971 Job Number. Walgreens 19981 We aresending yon ,t ❑ Attached ❑ Under Separate Cover via: [Type text here] the following: ❑ Shop Drawings ❑ Prints ❑ Plans ❑ Other: ❑ Copy of Letter ❑ Change Order ❑ Samples ❑ Total Quantity ❑ Reproducible ❑ Specification sabirnittal .Quant iky: Date: DWG. #�� =Description, -, ipg 05/06/21 Transmittal ipg 05/06/21 Check#1142 For Building Permit Application 2pgs 05/06/21 Building Permit Application ipg 05/06/21 Unit Location Map 1pg 05/06/21 Check#1143 For Electrical Inspection 1pg 05/06/21 Application for Electrical Inspection 4pgs 05/06/21 Insurance Certificates 1pg 05/06/21 Suffolk County License 4 Sets 44pgs 05/06/21 York Unit Submittals .G"omments: 1111 Route 110 PHONE 631-274-7002 Suite 353 - .FAX 631-883-7373 Farmingdale; NY 11735 5/5/2021 10095 NY-25-Google Maps oo& Maas 10095 NY-25 `- •: '�t �'t v- `- `els,, '"1 .,' x ,, OR ''.`-; Yt✓V, WOW ",�ry} �:'b`; sayy�,��'��•� ('„y"�d�":� �'h.,.+ .�.w s s4g��,.gc,,c a+ sr�� p-p� "-;;,, i',C.J'�; r 4r_p. �'8"` ` ;.25 -�a��a'� ', LT, xr+ti '__��x' 1�� �_ 14 7'l,��r�,-"�€ •,� r� ��-},�ti$q.-� ".\5��,�'' �r4� r#� aa. ,{ ;y�a��+����f19"°7¢��-r `' , �eMA�1, � ".titer_ X `'`�,�'y'3'�•a6.'r,i 5-- � "''�;: - °'�+u�, r }.` ;, h m; �r�£d1 R� �A��E,.�g�� A `�I.: _ ���--' 'Mr's �� ��� ;•,4-±i�8 £ 1, `�t,- T���= w,�" "• .�,. R'�S"'i�>� ��� r � �> ��'hs6� ♦ f ,�,�,��p fry - Imagery 02021 Maxar Technologies,New York GIS,Map data©2021 20 ft https:ltwww.google.com/maps/place/l0095+NY 25,+Mattituck,+NY+11952/@40.9861303,-72.5380844,103m/data=13m1!1 e3l4m513m411 sOx89e88e13dO6b2ee9:Ox58064c46add88eaO!8m2l3d40.98589... 1/3 Small Sunline 3-6 Ton Page:3 UVORIC Packag e 0 York Single Package R-41 OA Air Conditioner Project Name: 19981 -Mattituck,NY-REV 3 Unit Model#: ZE060H12B4A1AAA1A2 Quantity: 2 Tag#:RTU-2,4 System: ZE060H12B4A1AAA1A2 Cooling Performance - Total gross capacity 58.9 MBH "° r,�x -' 9 P ty �L :;�;,_ax" �'gP $ 3 n• Sensible gross capacity 48.0 MBH �� " s- Total net capacity 56.0 MBHPa6, Sensible net capacity 45.1 MBH ' Seasonal Efficiency(at ARI) 14.00 SEER Efficiency(at ARI) 11.80 EER Ambient DB temp. 85.2 °F Entering DB temp. 77.0 °F Entering WB temp. 62.8 °F _a Leaving DB temp. 51.6 °F Leaving WB temp. 50.9 °F Latent Dew Point 50.40 °F Power input(w/o blower) 3.71 kW Sound power 82 dB(A) Refrigerant Refrigerant type R-410A S s1 6 lbs 4 oz Gas Heating Performance 5 Ton Entering DB temp. 60 °F York Units are Manufactured at an ISO 9001 Registered Facility and Each Heating output capacity(Max) 100 MBH Rooftop is Completely Computer-Run Tested Prior to Shipment. Supply air 1750 CFM Unit Features Heating input capacity(Max) 125 MBH Leaving DB temp. 112.9 °F . Single Stage Gas'Aluminum Steel Air temp.rise 52.9 °F • Single Stage Cooling SSE 80.0 % • 125 MBH Input Stages 1 • Unit Cabinet Constructed of Powder Painted Steel,Certified At 750 Hours Supply Air Blower Performance Salt Spray Test(ASTM B-117 Standards) Supply air 1750 CFM • Either Supply and/or Return can be Field Converted from Vertical to Ext.static pressure 0.6 IWG Horizontal Configuration without Cutting Panels. Addl.Unit Losses(Options/Accessories) 0.09 IWG • Full Perimeter Base Rails with Built In Rigging Capabilities Blower speed 1058 RPM . Scroll Compressor Max BHP of Motor(Including service factor) 1.73 HP . 1 Duct location Bottom .5 HP Standard Static Belt Drive Blower Motor rating 1.50 HP • Unit Ships with 1"Throwaway Filters Actual required BHP .92 HP • Solid Core Liquid Line Filter Driers Power input 0.86 kW . Replacement Filters-2-(15"x 20"x 1"or 2")and 1-(14"x 25"x 1"or 2"). Elevation 335 ft. Unit accepts 1"or 2"wide filters. Drive type BELT . Single Point Power Connection Outside/Mixed Air • Through-the-Curb and Through-The-Base Utility Connections Outside Air Cfm 350 CFM . Short Circuit Current:5kA RMS Symmetrical Outside Air temp. 85.2 °F Microchannel All Aluminum Condenser Coil,Co er tube/Aluminum fin Outsided Airr WB temp. 70.7 °F PP Outside Air RH 49.2 % Evaporator Coll Return Air CFM 1400 CFM • Galvanized Steel Drain Pan Return Air DB temp. 75 °F . Standard Access Doors Return Air WB temp. 60.6 °F Return Air RH 43.2 % Standard Unit Controller: Smart Equipment Control Board Electrical Data • An Integrated Low-Ambient Control,Anti-Short Cycle Protection,Lead-Lag, Power supply 460-3-60 Fan On and Fan off Delays,Low Voltage Protection,On-Board Diagnostic Unit min circuit ampacity 14.1 Amps and Fault Code Display.Allows all units to operate in the cooling mode down Unit max over-current protection 20 Ams to 0°F outdoor ambient without additional components or intervention. Dimensions&Weight • Safety Monitoring-Monitors the High and Low-Pressure Switches,the Hgt 33 in. Len 83 in. Wth 45 in. Freezestats,the Gas Valve,if Applicable,and the Temperature Limit Switch Weight with factory installed options 712 lbs. on Gas and Electric Heat Units.The Unit Control Board will Alarm on Ignition Clearances Failures,'Safety Lockouts and Repeated Limit Switch Trips. Right 24 in. Front 32 in. Rear 12 in. Warranty Top 72 in. Bottom 0 in. Left 24 in. • One(1)Year Limited Warranty on the Complete Unit Note: Please refer to the tech guide for listed maximum static pressures • Five(5)Year Warranty-Compressors and Electric Heater Elements ® • Ten(10)Year Warranty-Aluminized Heat Exchanger AMmicae Information is subject to change without notice.Check local codes Pnnted 07/14/2021 Small Sunline 3-6 Ton Page:4 M Y©RK® Package York Single Package R-41 OA Air Conditioner Project Name: 19981-Mattituck,NY-REV 3 Unit Model#: ZE060H12B4A1AAA1A2 Quantity: 2 Tag M RTU-2,4 System: ZE060H12B4A1AAA1A2 Factory Installed Options ZE060HI MA1AAA1A2 Equipment Options Option(s) Selected "",,..x..i�� _ w t„ v� w." c�,Si�?91��eP���ged,F�„=4�10AAt�Car�dtioner:` a ,�,.,Cm�`�en.'»'"' �° `tl.3 P�`���x�x ,�.,-`"�`'�:J.;,k:."a'?',: �,o�"t s�.`~�•� ,..z= r, � �ws- �, < Nominal Cooling Capacity: 060 5 Ton - Single Stage Cooling ��,,F�"�' � ��� w°„ N,.w,"' �'�.TM �j °� '•°Stn"""lelSta eGa Its ,,i�n.,'��"St 'I°„`.�����. � °,�;�° _,�` �4,Z, Blower Option: B 1.5 HP Standard Static Belt Drive Blower �".�;�x�N�” "" »��^"' ,J`,.N�l., i"��"-' :w�� � �.°"�aM'� � .;»n �`p'^n ".w,":�•�}t'... - '�v" °iar'.,'" off.^-::i•``. ."�„'+;���<< „`w A,.�,,."' ;d».,-�n". � a° r Outside Air Option: A €neZ: ,,_^'3�n M"4F: �� °i ...p�n!'�U-��"'�`!`�' =-"^", +'�`'�'. z ��' ���”"ai yb� ""y w;:<<;.�>,'' ;xa�°`,`-+?;��;�ya r�^` -ij�"�x• �M�`�`�",�„xr�,. `"`, ,, :.csg.,,3•F 'aka'$ A >trk�,�`^. ' �.Ns ` '+a,K."''.; Sensor Options: 'A fir` i ochatelAlIL1tt11111i4n a �, �'1, �/�01„ O `f:@�� Po,•,� � '�',�'< Additional Options: , 'I 1"Throwaway Filters "�'"w ,�' �1.R ,� .��'*� '�'°&°„ q,-�;«�.,°; w e`' '�,��� �� .� � �°� �,, �,� "''�a� dr•",� �'m;s dta. � ¢-.=y w � �m , a,'�.,�:°`.r°R�- �'"� ;£,�"^"F .;;�- .,`_:�'zCabitielrr{Qp#ions, ,�.w .4�R,�g.� ,. r�_ �> s.�•° � � . � c`ti�°���<� Field Installed Accessories O 1 BD0401 -Burglar Bars(25.0 lbs) O 1 LN0406'-Low NOx Kit- O 2DF0403-Dirty Filter Switch (1.0 O 1CG0401 -Coil Guard (11.0 lbs) Required to reduce the emission lbs) of nitrogen oxides below 40 0 2EE04709024-D Bulb Low O 1 C uset, -Concentric nano rams per joule. Leak Economizer Hood Kit Diffusei•,Flush Mount,18RD g p � ( O 1 CV0411 -Concentric O 1 NP0440-Natural Gas to included for field assembly and Diffuser,Side Discharge,1 8RD Propane Conversion Kit(1-Stage) installation)(50.0 lbs) (55.0 lbs) (1.0 Ibs) 40 1 RD0410-Barometric Relief O 1 CV0419-Concentric O 1 RC0434-Roof Curb- 14" High, , Damper with Hood Kit(Downflow Diffuser,Specialty,18X18 Flat, Uninsulated, Full Perimeter Unit or Duct Mounted)(6.0 lbs) O 1 FA0403-Manual O.A. Damper (Shipped Knocked Down)(86.0 0 1 RD0410-Barometric Relief with Hood Kit-0%to 35% lbs) Damper with Hood Kit(Downflow Capability'(9.0 lbs) O 1 RC0442-Roof Curb 12" High, Unit-or Duct Mounted) (6.0 lbs) O 1 FA0404-Manual O.A. Damper Flat, Uninsulated, Full Perimeter ' O 2AQ04700524-CO2 Space with Hood Kit-0%to 100% (Shipped Knocked Down) (78.0 Sensor-Wall Mount Accessory Capability(15.0 lbs) lbs) (5.0 lbs) O 1 FE0405-Flue Extension Kit O 1 RC0465-Roof Curb-8" High, O 2AQ04700624-CO2 Unit Mount (25.0 lbs) Flat, Uninsulated, Full Perimeter Accessory(4.6 lbs) O 1 GP0401 -Gas Piping Kit for (Shipped Knocked Down)(67.0 O 2PE04703746- Power Exhaust Bottom Gas Supply Connection lbs) Kit-460-3-60 (65.0 lbs) with External Shut-Off(includes: O 1 WC0411 -Wooden Crate for O 2EE04709124- BAS Low Leak Internal gas pipe,fittings,gas cock extra protection during shipping Economizer with 2-10VDC &panel gaskets) (5.0 lbs) and handling (302.0 lbs) Actuator w/o Barometric Relief O 1 HG0413-Hail Guard Kit(51.0 O lbs) 0402-Air Proving Switch (1.0 (50.0 lbs) lbs) information is subject to change without notice.Check local codes. Printed,07/14/2021 Date , 07/14/2021 Project Name 19981-Mattituck,NY-REV 3 Project Number Client/Purchaser Submittal Summary Page Qty Tag# Model#/Material# Description 2 RTU-2,4 ZE060H12B4A1AAA1A2 5 Ton, Single Packaged R-41 OA Air Conditioner, Single Stage Cooling, 11.8 EER/14.0 SEER, Single Stage Gas Aluminum Steel, 125 MBH Input,460-3-60 • 1.5 HP Standard Static Belt Drive Blower • 1"Throwaway Filters • Microchannel All Aluminum Condenser Coil, Copper tube/Aluminum fin Evaporator Coil • Galvanized Steel Drain Pan •Standard Access Doors nx:;._<.wt•,+'", ,�ae ;a .`a wR.., S`,_Ca3,<.0.w`4r:< - ^x*.eF>�"''s4. `ie ., ,s y tau#ar-',"'e F,°i'" y„ e,l�,..,e,s*i7�tsvn., '"en''fmw:g.w",noa7' 2 3. ;444 r <, " A w .(,, ra "� e+'. 2 ' RTU-2,4 S1-SE-COM1001-0 Field Installed Communication Card for Simplicity SE control. Can be field configurable for BACnet, N2 or ModBUS MSTP Orel; t 1"Wifed,`lnctrSri"�„y twa hirrri' senso } 5 ��. 2 RTU-2,4 1 RD0410 Barometric Relief Damper with Hood Kit(Downflow Unit or Duct Mounted) , '"a .- i, "'-� �".'-•�^ Y av s&, '° *>> «<,'�,+Y > �, TR (,,,s -`a�"^zc P "y .v til II.. "r >,.,a., ,,,.,,?,rc,"<,^.,rf,.ms-t. « Equipment start-up and commissioning by a factory trained technician is recommended. Contact your supplying distributor or sales representative for additional information &guidance. w WARNING:Cancer and Reproductive Harm-www.P65Wamings.ca.gov Information is subject to change mnthout notice.Check local codes. Printed 07/14/2021 Date 04/26/2021 " Project Name 19981 -Mattituck,NY a , Project Number Client/Purchaser Submittal Summary Page Qty Tag# Model# Description 2 RTU-2, 3 ZJ06lNl2D2B5GCA2R3 5 Ton, Single Packaged R-410A Air Conditioner, High Efficiency, Single Stage Cooling, 14.5 SEER/ 12.2 EER, 120 MBH Input Aluminized Steel, Two Stage Gas Heat, 208/230-3-60 • Dry Bulb Low Leak Economizer w/Barometric Relief and Hoods (Bottom or Horizontal End Return Only)with Economizer Fault Detection & Diagnostic(Meets ASHRAE 90.1-2013, IECC 2015, California Title 24, AMCA 511). • 2 HP High Static Belt Drive Blower • 2" Pleated Filters (MERV 8) • Smart Equipment Controller including Discharge Air, Return Air, and Outdoor Air Temperature Sensors. BACNet MS/TP, Modbus and N2 Communication Card. • Non-Powered Convenience Outlet • HACR Circuit Breaker/Disconnect • Supply Air Smoke Detector • Phase Monitor • Micro-Channel "all-aluminum" condenser coil, Copper tube/aluminum fin evaporator coil • Composite Drain Pan - Back Connection ,.,�;� . _> ,� �,,�,,:< r�,�;F^ Y;r��'a F2TF1-2ti 3m r 4 AQ()4700524= v 't' CO`°S ace.Sen`sor-.Wall,`Nlount=Accessp =2 '��:•,� ,�. �:,. � ��"��aa� .<;�.�� � �,v� ^,��aw. ° ^��<�,,�„s.�->.._.<p.,,°�.� .^.�. ���� .- �� ''a`, �,��,�. .."ro .,�ry�".'<_:`�,���'-�w�'��s�P��-�^» 2 RTU-2, 3 2ECO402 Kit, Dual Enthalpy Field Installed (Includes two humidity sensors) T,; F21tJ=4° r. ZR061N12D264GCA1A2:`; ,5 Tori,"SinIe F'acka ed-R�41'OA,Air,`'Cor ditiarier; Standard, icieric l!?E 9F. 9 ,, x 14'.2SEER/Y 1.2:1=rEER, M"a"iiaD- "with'Reheat;Y.1.20<,MBH-Input v v"° - ; R° Aluminized Steelrt'Two,Sta `eGa's"Heat,208%230-3=60 , r, " : u,4 4=v,• D"` Bulb`Lo`w 3Leak,E`cononi'zer w/Barometric Relief and<'�("7(oods t- ' y �.. �.,.E'"Cc:6`> '�`t-+s''�a 1."'i5:" +>`.s�""<s£`�J r 'x R:;?a< e�".y" .`,�,.`„ ? ,_x �" '`� y'>"vx✓,yF.«nj Rt 3`� ��'� �'M '� a;�> '-��a �„Bottom'oreHor_izorital�Eridhfte u'rnbOnl''viiifih�EcoraamizerTFaul't -k'�” Defe�cti6 &<Dia`nostic'(MeetsaASHRAE4,90:1-20`.13, IE`CG 2015; -3,ZHP,Hi`Th,Stati,c Belt Drive,Blower'. M tiw �Sfandard2 Throwaway Filters ,� . K Vii. - .Y Smart.E ui`menfi:Controlle�includir+ Dischar a Air;-.Returri rd'!F � MS'TP /odii N2'C`omimiriicatio°nzCard.1;=-�^ , _^'�; .,»• < �xr xF s ', Kx . R°owered`<Co`nienis'nce Outlet('1,10:VAC-%15 Am -: nirty'Filter,'Switcfi t •tMicro-Chianneel„"lall=aluminum”condenser coil fico' 'er`x ° P '. ;"` lurri'inumfin`eva" orator`=coif x:""N"��'= 1 RTU-4 2SDO4700824 Smoke Detector Kit w/ Mounting Hardware for Supply Air (Horizontal/Downflow) Only Information is subject to change without notice.Check local codes Printed 04/26/2021 Qty 7a8# Model# Description 1 Condenser and Base R Factory coated condenser coil aowell anthe base rails. ail Coat ® York® Sun TM Pro 3-12.5 Ton Page-4 MYORK Package Single Package R-41 OA Air Conditioner Project Name, 19981 -Mattituck,NY Unit Model#: ZJ061N12D2B5GCA2R3 Quantity: 2 Tag#'RTU-2,3 System: ZJ061 Nl2D2B5GCA2R3 Cooling Performance Total gross capacity 609 MBH 1, 3 %;a43az �� � � Sensible gross capacity 41 7 MBH �a��. °ems .�� .,. m€.;�,,:', - '� Total net capacity 565 MBH °�� � � � � � :° Sensible net capacity 373 MBH x Seasonal Efficiency(at ARI) 1450 SEER Efficiency(at ARI) 12.20 EER °tea Ambient DB temp 92.2 °F �, Entering DB temp. 787 °F Entering WB temp Leaving DB temp. 54.9 °F `; Leaving WB temp. 52.3 °F Power input(w/o blower) 389 kW Sound power 77 dB(A) wa. " Refrigerants Refrigerant type R-41 OA S s1 7 lbs 8 oz Gas HeatingPerformance 5 Ton Heating output capacity(Max) 97 MBH Entering temp 60 - York Sun Pro units are manufactured at an ISO 9001 registered facility and M Supply air 1625 CFM each rooftop is completely computer-run tested prior to shipment. Heating input capacity(Max) 120 MBH Unit Features Leaving DB temp 115.3 °F Air temp rise 55.3 °F Single Stage Cooling SSE 81 0 IN, • 120 MBH Input Aluminized Steel,Two Stage Gas Heat Stages 2 - Unit Cabinet Constructed of Powder Painted Steel,Certified At 750 Hours Supply Air Blower Performance Salt Spray Test(ASTM B-117 Standards) Supply air 1625 CFM • Full perimeter base rails with built In rigging capabilities Ext.static pressure 1.88 IWG - Dry Bulb Low Leak Economizer w/Barometric Relief and Hoods(Bottom or Addl.Unit Losses(Options/Accessories) 011 IWG Horizontal End Return Only)with Economizer Fault Detection&Diagnostic Blower speed 1188 RPM (Meets ASHRAE 90 1-2013, IECC 2015,California Title 24,AMCA 511). Max BHP of Motor(including service factor) 230 HP - 2 HP High Static Belt Drive Blower Duct location Bottom MERV 8l - Unit Ships with 2"Pleated Filters Motor rating 2.00 HP p ( ) Actual required BHP 1.39 HP - Solid Core Liquid Line Filter Driers Power input 1 30 kW - Replacement Filters.4-(24"x 16") Unit accepts 2"or 4"wide filters Elevation 30 ft. - Non-Powered Convenience Outlet Drive type BELT - HACR Circuit Breaker/Disconnect Outside/Mixed Air - Short Circuit Current.5kA RMS Symmetrical Outside Air Cfm 350 CFM - Single Point Power Connection Outside Air DB temp. 922 °F Outsided Air WB temp. 74.4 °F - Through-the-Curb and Through-the-Base Utility Connections Outside Air RH 439 IN, - Supply Air Smoke Detector Return Air CFM 1275 CFM - Micro-Channel"all-aluminum"condenser coil,Copper tube/aluminum fin Return Air DB temp 75 °F evaporator coil Return Air WB temp 62 °F - Composite Drain Pan-Back Connection Return Air RH 481 % - Tool-free maintenance with features like hinged doors for all-access panels, Electrical Data slide-out blower and blower motor tray Power supply 230-3-60 Standard Unit Controller: Smart Equipment Control Board Unit min circuit ampacity 26 5 Amps Unit max over-current protection 35 Ams • Safety Monitoring-Monitors the High and Low-Pressure Switches,the Dimensions&Weight Freezestats,the Gas Valve,if Applicable,and the Temperature Limit Switch Hgt 42 In Len 89 in. With 59 In on Gas and Electric Heat Units.The Unit Control Board will Alarm on Ignition Weight with factory installed options 955 lbs Failures,Safety Lockouts and Repeated Limit Switch Trips. Clearances Warranty Right 12 in. Front 36 in. Rear 36 in. - One(1)Year Limited Warranty on the Complete Unit Top 72 in Bottom 0 in. Left 36 in • Five(5)Year Warranty-Compressors and Electric Heater Elements Note Please refer to the tech guide for listed maximum static pressures - Ten(10)Year Limited Warranty-Aluminized Steel Heat Exchanger no m`� r O.UALIT"Y �\ ��\ LAMERICAN Uzi, ING-u sS � fj\(� Information is subject to change without notice Check local codes Printed 04/26/2021 York® Sun TM Pro 3-12.5 Ton Page 5 WYORK Package Single Package R-41 OA Air Conditioner Project Name: 19981 -Mattituck,NY Unit Model#: ZJ061 Nl2D2B5GCA2R3 Quantity: 2 Tag#:RTU-2,3 System: ZJ06lNl2D2B5GCA2R3 Factory Installed Options ZJ061 Nl2D2B5GCA2R3 Equipment Options Option(s) Selected _ "c�,,'7,.,*' ;r`<:"�'jk''=�ti,. "2'w° `?.��" I L"�'>`�'�°"e ;, �-:�•, „ a_:.........MxR-^'MW"M."A Air C:/o..findi�t^io\,�r1ixeVr;a:H''�vi""-�h✓vxin le«FPack1 �Efficit'Categry:Procuc yrs;'; a'`a;✓°. ',�°'-;:,' - r„-`; ,s.. =�� ;�,',. :�3° ' .;�`,�=g"`°"', 2"2tiEER" a SEER"�fx1 .'X.:%,:.. a......:�''` .,,.,...:..:.'r.-`".°e..n:,��"M.,..........,.�'�"v.>:.��:..x?�'�^,��.,..- "s."':x.....",....::..x�...<.::F.,.....,..,,»....,?.�..ww;;s,.:c:�.";.�.._,_....,...°...,.«._....s.,.o,.,:..�...... ..�"x�;»,�....5..s................�.�. Nominal Cooling Capacity: 061 5 Ton Single Stage Cooling x'y"�9:" 'F° - %, , f -u xis.,°tr i✓%�q ;. HeatxTypeiand Nominal,;Heat Capacity:=u7N12'° 120=MBH�Inp'u"t Aluminized°Steel„Two Stage Gas°Heat” >i Yl Blower Option: D 2 HP High Static Belt Drive Blower 270 .�.°,7x. e,t9i.»✓'�„ w�3e '�a - Dry Bulb Low Leak Economizer w/Barometric Relief and Hoods(Bottom or Horizontal End Return Only)with Outside Air Option: B- Economizer Fault Detection & Diagnostic(Meets ASHRAE 90.1-2013, IECC 2015, California Title 24, AMCA 511). i ate '715a"'40`On powered^Convenienutle ce t° sP `^e `*, @tV�G@ O tions: s , «`= p HA ircuit Bre ke>/,Di tt a k. o o; e CRC' a,< r sconhect= Sensor Options: G Supply Air Smoke Detector : - ` Y < �- - , t SatEqpm ;Coit ilIef„i cIudin9�D�chd, 6,,Air' T .n`" `q°, `,4 s_`�' 4> n3zs�,? „Return Arf arid0utc(oorAir`Temperatur >Sensors. g`'�. '' , .,= °"xt>*`S° 1.'^s` qas ... •-' .�"+, _�,« `sr,'.x et- S%Ti?Modbus.and N2 Communic2fii'on Gard: � ^+s:;° :1 '.3=-b' `a-t^,;z;e'<�„ -*'a�"r4".,,'.,ixr' �" ,>`'�:.�, _�,�'" �,,ri';t..��-'_; ��`«r°t;•,:>a�„ ��`;;t�'r�71 � r•�s��”-,,, �s.�`".�,Wy„ �'*�s.�rYw;,,�":-'°:'N. .�,.� Refrigeration: A Micro-Channel "all-aluminum"condenser coil, Copper tube/aluminum fin evaporator coil "' 2 Pleated3Filters``,`NIRV 8 ° afAdditionat t3ptiotrj"s:" , 2`'^% y_ t h . �p,,^ �.,.w..,.�.,.,a.�c .a�a.»..,..«.:'.«-.,w.'s,..,^..,.,ne.,.w.., .:a.:: :ria.rs.C..,- Cabinet Options: R Composite Drain Pan-Back Connection Peddu"ct Generation; L rt Field Installed Accessories O 1 BD0408- Burglar Bars (32.0 lbs) O 1 FE0412- Flue Exhaust O 1 HA0452 - High Altitude Kit for O 1 CG0428 -Coil Guard (20.0 lbs) Extension Kit(14.0 lbs) Propane (1.0 lbs) O 1 CV0402-Concentric O 1 FF0415 -2" Only metal Filter O 1 HG0415- Hail Guard Kit- Diffuser,Flush Mount,18RD Frame Kit (16.0 lbs) Diamond Pattern (50.0 lbs) O 1 CV0411 -Concentric O 1 GP0405- Gas Piping Kit for O 1 HG0431 - Hail Guard Kit- Diffuser,Side Discharge,1 8RD Bottom Gas Supply Connection Provent Style (20.0 lbs) (55.0 lbs) with External Shut-Off(includes: O 1 LN0407- Low NOx Kit O 1 CV0419- Concentric Internal gas pipe, fittings, gas cock p 1 NP0460- Natural Gas to Diffuser,Specialty,18X18 & panel gaskets) (10.0 lbs) Propane Conversion Kit(2.0 lbs) O 1 HA0450 - High Altitude Kit for Natural Gas (1.0 lbs) Information is subject to change without notice Check local codes Printed 04/26/2021 York® Sun TM Pro 3-12.5 Ton Page 6 WYORK® Package Single Package R-41 OA Air Conditioner Project Name 19981 -Mattituck,NY Unit Model# ZJ061N12D2B5GCA2R3 Quantity. 2 Tag#.RTU-2,3 System ZJ06lNl2D2B5GCA2R3 O 1 RC0470- Roof Curb -8" High, O S1-ADDWIRE-Add-a-Wire allows O S1-NSB8BHN240-0 -Wall Flat, Uninsulated, Full Perimeter 5-wire thermostats to use only 4 Temperature and 3% Relative (Shipped Knocked Down) (135.0 wires. (0.3 lbs) Humidity Combined Sensor, Full lbs) O S1-CTSDTS -CTS Wired Display, WHITE, JCI LOGO, O 1 RC0471 - Roof Curb- 14" High, Temperature Sensor for NS8000 Series (0.4 lbs) Flat, Uninsulated, Full Perimeter thermostat I Duct*Also works for O S1-NSB8BHN241-0 -Wall (Shipped Knocked Down) (135.0 LX Series (0.3 lbs) Temperature and 3% Relative lbs) O S1-CTSHTS -CTS Hardwired Humidity Combined Sensor, Full O 1 RC0476- Roof Curb -24" High, Temperature Sensor for CTS Display, WHITE, NO JCI LOGO, Flat, Uninsulated, Full Perimeter Thermostats *Works with LX NS8000 Series (0.4 lbs) (Shipped Knocked Down) (135.0 series as well (0.2 lbs) O S1-NSB8BHN243-0 -Wall lbs) O S1-CTSPLATE-Wall Plate for Temperature and 3% Relative O 1 WC0412-Wooden Crate (445.0 CTS Thermostats*Also works for Humidity Combined Sensor, Full lbs) new platform LX series models Display, BLACK, NO JCI LOGO, O 2AP0402 -Air Proving Switch (1.0 below (0.0 lbs) NS8000 Series (0.4 lbs) lbs) O S1-CTSWFTS - CTS Temperature O S1-NSB8BPN240-0 -Wall • 2AQ04700524 -CO2 Space Sensor with WiFi for CTS Temperature and 2% Relative Sensor-Wall Mount Accessory Thermostats *Also works with LX Humidity Combined Sensor, Full (5.0 lbs) Series (0.1 lbs) Display, WHITE, JCI LOGO, O 2AQ04700624-CO2 Unit Mount O S1-LXLOCK- Locking Ring For NS8000 Series (0.4 lbs) Accessory(4.6 lbs) LX-Series Thermostats (0.4 lbs) O S1-NSB8BPN241-0 -Wall O 2ECO401 - Kit, Single Enthalpy O S1-LXPLATE-Wall Plate For LX- Temperature and 2% Relative Field Installed (1.0 lbs) Series Thermostats (0.0 lbs) Humidity Combined Sensor, Full • 2ECO402- Kit, Dual Enthalpy O S1-LXWFM - For LX Series Display, WHITE, NO JCI LOGO, Field Installed (Includes two Thermostats-WiFi NS8000 Series (0.4 lbs) humidity sensors) (1.0 lbs) Communication (1.0 lbs) O S1-NSB8BPN243-0-Wall O 2LA04702412- Low Ambient Kit O S1-MP-PRTKIT-0P- MAP Temperature and 2% Relative (2.2 lbs) (Multiple Access Portal) Gateway Humidity Combined Sensor, Full O 2PE04704706- Power Exhaust Kit- Replacement MAP gateway Display, BLACK, NO JCI LOGO, 230V without Baro Relief protective case, lanyard and NS8000 Series (0.4 lbs) Downflow or Horizontal (19.0 lbs) communication cable. Use only to O S1-NSB8BTN041-0-Wall O 2SDO4700924-Smoke Detector replace worn or damaged Temperature Sensor, No Display, Kit w/ Mounting Hardware for components. (0.3 lbs) WHITE, NO JCI LOGO, NS8000 Return Air(Downflow Only) Only O S1-NSB8BHN041-0-Wall Series (0.4 lbs) (10.0 lbs) Temperature and 3% Relative O S1-NSB8BTN043-0-Wall O S1-02812496000- Blower Sheave Humidity Combined Sensor, No Temperature Sensor, No Display, AK79 Field Installed Drive (4.0 lbs) Display, WHITE, NO JCI LOGO, BLACK, NO JCI LOGO, NS8000 O S1-03102529000 - Non- NS8000 Series (0 4 lbs) Series (0.4 lbs) Networking Wall Sensor-Allows O S1-NSB8BHN043-0-Wall O S1-NSB8BTN141-0 -Wall remote sensing and control from Temperature and 3% Relative Temperature Sensor, single or multiple zones. (0.2 lbs) Humidity Combined Sensor, No Warmer/Cooler Display, WHITE, O S1-03102529004- Non- Display, BLACK, NO JCI LOGO, NO JCI LOGO, NS8000 Series Networking Wall Sensor with NS8000 Series (0.4 lbs) (0.4 lbs) Over-ride button-Allows remote O S1-NSB8BHN141-0-Wall O S 1-N S B8BTN 143-0-Wall sensing and control from single or Temperature and 3% Relative Temperature Sensor, multiple zones. Override allows Humidity Combined Sensor, Warmer/Cooler Display, BLACK, setpoint to be overridden for 2 Warmer/Cooler Display, WHITE, NO JCI LOGO, NS8000 Series hour time period. (0.2 lbs) NO JCI LOGO, NS8000 Series (0.4 lbs) O S1-03102529006- Non- (0.4 lbs) O S1-NSB8BTN240-0-Wall Networking Wall Sensor with O S1-NSB8BHN143-0-Wall Temperature Sensor, Full Display, Setpoint Adjustment and Over-ride Temperature and 3% Relative WHITE, JCI LOGO, NS8000 Button-Allows remote sensing Humidity Combined Sensor, Series (0.4 lbs) and control from single or multiple Warmer/Cooler Display, BLACK, O S1-NSB8BTN241-0 -Wall zones. Allows setpoint to be NO JCI LOGO, NS8000 Series Temperature Sensor, Full Display, adjusted ±5° F. Override allows (0.4 lbs) WHITE, NO JCI LOGO, NS8000 setpoint to be overridden for 2 Series (0.4 lbs) hour time period. (0.2 lbs) Information is subject to change without notice Check local codes Printed 04/26/2021 ® York® Sun TM Pro 3-12.5 Ton Page-7 11YORK Package Single Package R410A Air Conditioner Project Name: 19981 -Mattituck,NY Unit Model# ZJ061 N12D2B5GCA2R3 Quantity: 2 Tag#:RTU-2,3 System ZJ06lNl2D2B5GCA2R3 O S1-NSB8BTN243-0-Wall O S 1-TEC3023-16-000- 7 DAY O S1-TEC3613-14-000-7 DAY Temperature Sensor, Full Display, PROGRAMMABLE PROGRAMMABLE BLACK, NO JCI LOGO, NS8000 THERMOSTAT, ZIGBEE PRO THERMOSTAT, OPTIONAL MSTP Series (0.4 lbs) WIRELESS COMMUNICATION, OR N2 COMMUNICATION, O S1-TEC3012-14-000 -7 DAY FCUNAV, 0-10VDC PROP, OCC FCUNAV, ON/OFF OR PROGRAMMABLE & DEHUMID, FULL COLOR, FLOATING, OCC & DEHUMID, THERMOSTAT, ZIGBEE PRO WHITE, NO LOGO (0.8 lbs) FULL COLOR, WHITE, JCI LOGO WIRELESS COMMUNICATION, O S1-TEC3030-14-000 -7 DAY (0.8 lbs) FCUNAV, ON/OFF OR PROGRAMMABLE O S1-TEC3613-16-000- 7 DAY FLOATING, DEHUMID, FULL THERMOSTAT, ZIGBEE PRO PROGRAMMABLE COLOR, WHITE, JCI LOGO (0.8 WIRELESS COMMUNICATION, THERMOSTAT, OPTIONAL MSTP lbs) RTU/HEAT PUMP WITH OR N2 COMMUNICATION, O S1-TEC3012-16-000- 7 DAY ECON,FULL COLOR, WHITE, JCI FCUNAV, ON/OFF OR PROGRAMMABLE LOGO (0.8 lbs) FLOATING, OCC & DEHUMID, THERMOSTAT, ZIGBEE PRO O S1-TEC3030-16-000 -7 DAY FULL COLOR, WHITE, NO LOGO WIRELESS COMMUNICATION, PROGRAMMABLE (0.8 lbs) FCU/VAV, ON/OFF OR THERMOSTAT, ZIGBEE PRO O S 1-TEC3622-14-000 - 7 DAY FLOATING, DEHUMID, FULL WIRELESS COMMUNICATION, PROGRAMMABLE COLOR, WHITE, NO LOGO (0.8 RTU/HEAT PUMP WITH ECON, THERMOSTAT, OPTIONAL MSTP lbs) AND FULL COLOR, WHITE, NO OR N2 COMMUNICATION, O S1-TEC3013-14-000 -7 DAY LOGO (0.8 lbs) FCUNAV, 0-10VDC PROP, PROGRAMMABLE O S1-TEC3031-14-000 -7 DAY DEHUMID, FULL COLOR, THERMOSTAT, ZIGBEE PRO PROGRAMMABLE WHITE, JCI LOGO (0.8 lbs) WIRELESS COMMUNICATION, THERMOSTAT, ZIGBEE PRO O S1-TEC3622-16-000- 7 DAY FCU/VAV, ON/OFF OR WIRELESS COMMUNICATION, PROGRAMMABLE FLOATING, OCC & DEHUMID, RTU/HEAT PUMP WITH ECON, THERMOSTAT, OPTIONAL MSTP FULL COLOR, WHITE, JCI LOGO OCC SENSOR, FULL COLOR, OR N2 COMMUNICATION, (0.8 lbs) WHITE, JCI LOGO (0.8 lbs) FCUNAV, 0-10VDC PROP, O S1-TEC3013-16-000-7 DAY O S1-TEC3031-16-000 -7 DAY DEHUMID, FULL COLOR, PROGRAMMABLE PROGRAMMABLE WHITE, NO LOGO (0.8 lbs) THERMOSTAT, ZIGBEE PRO THERMOSTAT, ZIGBEE PRO O S 1-TEC3623-14-000 -7 DAY WIRELESS COMMUNICATION, WIRELESS COMMUNICATION, PROGRAMMABLE FCU/VAV, ON/OFF OR RTU/HEAT PUMP WITH ECON, THERMOSTAT, OPTIONAL MSTP FLOATING, OCC & DEHUMID, OCC SENSOR, FULL COLOR, OR N2 COMMUNICATION, FULL COLOR, WHITE, NO LOGO WHITE, NO LOGO (0.8 lbs) FCUNAV, 0-10VDC PROP, OCC (0.8 lbs) O S1-TEC3612-14-000-7 DAY & DEHUMID, FULL COLOR, O S1-TEC3022-14-000-7 DAY PROGRAMMABLE WHITE, JCI LOGO (0.8 lbs) PROGRAMMABLE THERMOSTAT, OPTIONAL MSTP O S 1-TEC3623-16-000- 7 DAY THERMOSTAT, ZIGBEE PRO OR N2 COMMUNICATION, PROGRAMMABLE WIRELESS COMMUNICATION, FCUNAV, ON/OFF OR THERMOSTAT, OPTIONAL MSTP FCUNAV, 0-10VDC PROP, FLOATING, DEHUMID, FULL OR N2 COMMUNICATION, DEHUMID, FULL COLOR, COLOR, WHITE, JCI LOGO (0.8 FCUNAV, 0-10VDC PROP, OCC WHITE, JCI LOGO (0.8 lbs) lbs) & DEHUMID, FULL COLOR, O S1-TEC3022-16-000 -7 DAY O S1-TEC3612-16-000-7 DAY WHITE, NO LOGO (0.8 lbs) PROGRAMMABLE PROGRAMMABLE O S 1-TEC3630-14-000- 7 DAY THERMOSTAT, ZIGBEE PRO THERMOSTAT, OPTIONAL MSTP PROGRAMMABLE WIRELESS COMMUNICATION, OR N2 COMMUNICATION, THERMOSTAT, OPTIONAL MSTP FCU/VAV, 0-10VDC PROP, FCU/VAV, ON/OFF OR OR N2 COMMUNICATION, DEHUMID, FULL COLOR, FLOATING, DEHUMID, FULL RTU/HEAT PUMP WITH WHITE, NO LOGO (0.8 lbs) COLOR, WHITE, NO LOGO (1.0 ECON,FULL COLOR, WHITE, JCI O S1-TEC3023-14-000 - 7 DAY lbs) LOGO (0.8 lbs) PROGRAMMABLE O S 1-TEC3630-16-000- 7 DAY THERMOSTAT, ZIGBEE PRO PROGRAMMABLE WIRELESS COMMUNICATION, THERMOSTAT, OPTIONAL MSTP FCUNAV, 0-10VDC PROP, OCC OR N2 COMMUNICATION, & DEHUMID, FULL COLOR, RTU/HEAT PUMP WITH WHITE, JCI LOGO (0.8 lbs) ECON,FULL COLOR, WHITE, NO LOGO (0.8 lbs) Information is subject to change without notice Check local codes Printed 04/26/2021 York® Sun TM Pro 3-12.5 Ton Page 8 MYORK ® Package Single Package R-41 OA Air Conditioner Project Name. 19981 -Mattituck,NY Unit Model#' ZJ061N12D2B5GCA2R3 Quantity 2 Tag#.RTU-2,3 System- ZJ061 Nl2D2B5GCA2R3 O S1-TEC3631-14-000-7 DAY PROGRAMMABLE THERMOSTAT, OPTIONAL MSTP OR N2 COMMUNICATION, RTU/HEAT PUMP WITH ECON, OCC SENSOR, FULL COLOR, WHITE, JCI LOGO (0.8 lbs) O S 1-TEC3631-16-000-7 DAY PROGRAMMABLE THERMOSTAT, OPTIONAL MSTP OR N2 COMMUNICATION, RTU/HEAT PUMP WITH ECON, OCC SENSOR, FULL COLOR, WHITE, NO LOGO (0.8 lbs) O S1-YK-MAP1810-OP - MAP (Multiple Access Portal) Gateway- For use with SimplicitySE Control. (0.2 lbs) O S1-YK-MAP1810-OS- Stationary MAP Gateway (Includes MAP Gateway, Field Bus Adapter, Mounting Bracket and 100 to 240 VAC Power Supply). US- compatible counties. (1.9 lbs) Information is subject to change without notice.Check local codes Printed 04/26/2021 York® Sun TM Pro 3-12.5 Ton Package Page 9 YORK Single Package R-410A Air Conditioner Project Name 19981 -Mattituck,NY Unit Model#: ZJ061 Nl2D2B5GCA2R3 Quantity: 2 Tag#:RTU-2,3 System: ZJ061 Nl2D2B5GCA2R3 Consolidated Drawing -- - ------ -------------------- - -- ---- - -------------------------------- ---- -,- -- - ----------- 2 --------2 3 4 S 6 7 A 9 IC II 2 13 14 15 '6 CENTER 1110155 z c=BRAT n1c O(SAAVI i• 1 I AOR OJTDOD9 USC O'N[Y. TONRACI WE1piI (L951 LCCAT ION iBASc OF'") 4 P01,:'CORNER LOADS iLESr (SASE UNIT) ' ? Wt IGPTS SHOW"i ARE tOR COOLING ONLY UN'TS i {BASE UNIT; ' A IA 19 U D K 3 It IN C,KARANCLS TO Bt, i 6 5 P128 861 T3 9-0 38,3�6$t1 ? Zq €661 2CC (91. 149=68- 218 y(991 292 11331 r RTGttT $IGt 12 13D51 32 886 1399; 39 1965,21 24 t600,61 203(y3, 1`3;65; 7231 01 299 11361 EBF- SIDE 36 1-157 [$300,,01 - 4 -- _ 1 7'1/73 8,!(;93 I A3 If016i Z6 f6EC„I �71[ [95, 111 ,18:� 21![391 �266 It211 :RI`NT 36 [91`1 6,83 I 6 5 L 15 1117€ 9,C 1413; I 3F 1965,7I 24 1609 61 ii7(561 1`9 17'� 730 1 Od' 399 I(/OI REAR 36 C915J :173,5] S Z1,LN 771 1369 40(10163 7d t6C9 61 i't [,ii A. =fi4, -405(331 15 II141 TOP. 1? (1$30: BOTTOM, 0 [01 24 38 4 N11 880[399' iI aG[10141 26 E66C,41 714 011 1'4(Y9; 2?1 11001 21 [1731 4 10 REMOVE T-E S,IOL-OUT )RAIN PAIR, A REA4 CL=ARARC_ Ot t6 9,21 s 7-R,➢N 80 t3M I 4D(10167 26 1£60,41 7n [967 172"iE; 2151991 FIT wil 6'0 13 (1525 W IS 1EOCJRLD IF SPAC= 'S UNAVAILAB_L, •IE ' 6 5 Z°Ilii 951 143:` 3E,955 27 23 1584,2] 714(alt 161^3' 249 t 131 33:11511 '.RAIN 'Ah CAM BE REMOVE TIT 'AE FRONT 6Y SEPAi1,T,Wa - - - - - - - - --�- -_ �_ TRE CORNER M B IS 00 7 8S 5' z91iN -'96>f439_ ;8'966377 -73 t_3E4,a1_-__216 t9B1 � let 13, P 1 ['le' -'-33, (1;11 5, rOk StrALIfR SF_RVICF AND OPERATIONAL CLEARANCES E45T,21 ' :;99,3] j _"' -;ilr 022 LATE 1 42 4'11011; 24 i 162•,41 2Cz faa'"�' 154'ea 2ss[ 16 �zs_uzel_ CONTACT YOJR APPL[CATION EFIC;NEER'IG DEPARTMENT 32 06 6 $2 4 i',2V 961[4361 47.5(1019,5"ZS S IEi- 11 211 I4S1 195 91- 260 1 IS' 285 11291 ' 6 3DWNF;.Ofi GJCTS DESIGNED TO BC ArrACHED TO ACC-SSORY :8 4,4: ;1"13,37 ZT12r 958{439 €41 6 LI056,6' 25 5(647,71 223 U91� 196 e9; 751[ 11• 1:.11331_ ROOF "URF ON Y Ir JNIT IS MO:JNTFD SI DF SJPPI.V I' �� - F IS RLCOVMENUED T6A1 THE DUCTS ARL SUPPORT"D BY 9 E0 47 18 25 F CIOSS BRAC,=_S, AS DONE ON AC(.CSSORY ROOT CJP,6S - ;265,51 i463,61 I 1 7 SIDF DOCT %LANDEES ARE ' '5 ['139 26 10 R - �---81 •I - t AETL;NATE CCNDcNSA-104 DP,41f1 ' BOTTOM DUCTS DO NOT HAVE F'_AM1ru° '66?,91� I J' 8 MINIMJM CONDENSATION TKA' HEIGHT SI-A-L BE 1 5 TIMES (:POM MT'"s127 SC i '24 00 '' iff T-F LC9ES" NEGATIVE STAT I" FLANGE'' J;698,51; C6C9,51 ", 9 I13EhSINS IN ' 1 ARE 19 VILL'ML2ERS OR •,ILOGRAM4 10 OPTIONAL 1'01, GJARDS, POWF$ EY,HALST. CAS ,{EAT LEFT + N1 i r / •!' 16 CO - I 27 75 G ECONOMIZER, DiSCONNEC7 SNITCH, CONVENIENCE OW-El, 11 ( » EC J 704,37 AND BA20MET€,IC RE' IEF , 'RESP AIR HOODS SHOWN "-- 7-L� RIGNT > II DE!C-E: - ti} SUPPLY \ tJ 12 $ TUBE HEAT ERCAANGFP, IS NOT AVAIL46.E :OR 3 4 TO'+ UNIiS ?0 33 20 14 9,14 ! i t5.8,L' 1,67 -d8G,2' I4 i 21 00-< 306,31 1435,41 [533'3,4' 41 L '-I F ' � ► DtR�"T[oN CF n,aF_ou __ I I 14 47 O ( FRONT '-BOTTOM GAS S 5 ;7 [75s4'� j 3 CFNTFR OF GRAVITY €35;,51 6 39 SUPP,,C ENTRY f 2 00 :50,8] 31,1] 5 31 [416,41 �-BOTTOM ENTR'f 1698,51 [504,91 28'uG REAR IPARTIAL V[EWI 1455,8; ''"WER¢2 50 !63,57 31 S•^,OVNEC-S421TCH COYER '$ 89 "OVTRO, 38 00 87� i?? ?31 1INIAY,E FOOD h01 SHOWN N 'h,a VIEW) 4,19.9: r F OL'S DE A'R-, MPT ONALI X ____ TOP VIEW N'ARc8000) C CP"I0NAI) 11 ?OWEH ENTR'02 50 (63,57 F.8 ?t _ �-+ 5109, 47551----- FRESH AIR HOOD,, :2240,4 l - LCONOMIZLRit ; (OrTICNA1} �--{{G-,AS INLET .--. Ci_ RA9rJ' - 9LCdgN ACCESS -- - D G 25 72 - - - CQMFP,F 5509 �\� ) , Em [653,3; Tcch'va[ssaa, CONTROL FNTRY 00 815 (22,%3)-`� ACCESS -- ACCESS I - POtJFfi %N<P,° S6? 50 i63,5:- 42,2_ _ _ o � . C�3 C BAROM;TR,C '7FI lt' HOOD/ a T . ac ! f ^a as '0'NLRr:SHA(;Sr / 2? 31--jl -�=� 21 9 '-- 3$ i LEFT VIEW (OP-IORAL) / [289,11 /// f693,6: '538,21 S59 r,0 CON'aEA,IENCE OCP_Ci "D`1ER / SE bGAIN ,DCA;tON DFTAIL 4 OR L-EX?AL'ST [1498,61 314' 1'T-- 50"T'ONAI} / F,UE -COIL GUAPD - / 89 OC RMT VIEW .0'T,ONAL1 B COHVENIENI„E O:,1LErJ L2260,62' FRONT VIEW g POWER ENTRY 0 0 8',5 122,237 10?T'ONA1. FRONT CO _ GI.RdD NOT SHOWN N Th,$ V17T, _ _ ' S 32 \ 9Ef .^ATE PEvI$IDB RECORD - µ^mmAv LE h�'iR(��IEN6 [HIP:A`h;,�inOJ[CTI AitlS f�pAXlr> .i tl0".J.'L i9,<S I'R Yt''.-,F�O.t. PAiT Os 9`It.•C_0[AaY t�f itf-0p S�A4i Yiti$ikCS FtR ['3),DJ I -' 1 • 1 A 02' -7Q NC4S DRAWING (FROM�$T-�R=C'20Dr'd2^)-� 97768 110"R^4;SAA INY6NYAil9>t JmN I:19 0,•10.5 Y 1NW YFIT_LY FEuLASE Nr YN,SCM L9%INOt3-- A:4]P ' 1 • L I • € M 6-tWKNi<Cf![SSs FIR A9•yFA�4r 5 7009 N4PL I C n --- TL 'LA$M 1OIL, 24ODF>442 ,B 0* NO' A"PEI-ICA 1 $ , " CAB ash sere NOT AP'_ICRP:F ,xa rLAtt uC1�a >: ' slit A A ��-A nwa t ,Kgta is`i TO PEwx c CIM4, t 0 G06 N0 C4 3 aVtA; 111.74 INN:(Pig 9[iIYAt' t 00 JO=NSON CONTROLS pC, pp'7 IRE SCALE 0 300 ENC s ACA, 171 21 K,-s- a 1' 3NIIARt 3IOm11*8 6RCIP WC ),-IRNI Ali 1s'eC.R<. YCRt;A4 O! `,Cc9 PM h0 SC. 0 - - 60 W,SME MITSIE NS I Cr ? 3 4 5 6 7 8 - 9 10 II ? 13 14 15 '6 Information Is subject to change without notice Check local codes Printed 04/26/2021 MYORK® York® Sun TM Pro 3-12.5 Ton Page-10 Package Single Package R-41 OA Air Conditioner Project Name 19981 -Mattituck,NY Unit Model#• ZJ061 Nl2D2B5GCA2R3 Quantity: 2 Tag#:RTU-2,3 System: ZJ061N12D2BSGCA2R3 Component Locations Component Location Cooling With Gas Heat(3 Through 5 Ton) Filter drier(solid core) Disconnect location Filter access 3-5 Ton Reheat (optional disconnect switch) (2"or 4" Micro-Channel Aluminum Smart Equipment"'Control board w/ filter options) Tube/Aluminum Fin screw connectors for stat / Condenser wiring and Networkrk ,C/ (s�ngie or1rce system shown ConnectionsSee Actual Model Physical Data for details) u= Slide out motor and rY, _,, blower assembly for M `°� ,, y." easy adjustment serviceSecond model nameplate �, - - „r� and service inside hinged access „ agy ` a ;` Filter drier(solid core) panel 3-5 Ton Cooling Base rails w/ Belt-drive blower vx forklift slots motor (three sides) ' and lifting Power ventor ' 5� t <+ X"' � holes ` , _ _ ;j `: motor 'spm y, '� 4SkPy>p"�t��+'F b"Et S�:Xy a :�w"•.'"` .e,�' �rw' Roof curbs in eight-and - r. h'E ,+;t;z 20-gauge aluminized 9 w Via , ��.> fourteen-inch heights. ,, " '�' M. __ steel tubular heat Roof curbs for transitioning _ exchanger for long life from York SunlineTM footprint � � (stainless steel option) to the ZH/ZJ/ZR ZU/ZW/ZK One or Two stage gas heating to Series footprint are available Side entry power (field-installed accessory) and control wiring maintain warm,comfortable knockouts Slide-out drain pan temperature Compressor access(high- with 1"NPT Intelligent control board efficiency compressor) connection for safe and efficient Toolless door operation latch Information is subject to change without notice Check local codes. Printed 04/26/2021 York® Sun TM Pro 3-12.5 Ton Page-11 MYORK Package Single Package R-41 OA Air Conditioner Project Name- 19981 -Mattituck,NY Unit Model# ZJ061 Nl2D2B5GCA2R3 Quantity 2 Tag#•RTU-2,3 System ZJ061N12D2B5GCA2R3 Low Leak Downflow Economizer Low Leak Downflow Economizer (shown with optional Power Exhaust) Fresh Air Hood (included) - �i Low Leak Economizer(included) ' Power Exhaust(optional) Barometric r Relief Damper Barometric Relief (included) Hood (included) Low leak economizers are capable-achieving low leakage rates of 3 cfm/sq. ft at 1" of static pressure, meeting or exceeding the following standards: ASHRAE 90.1-2010 ASHRAE 62 AMCA 511 (licensed as Class 1A damper) International Energy Conservation Code (IECC) California Title 24 The outdoor intake opening'shall be covered with a rain hood that matches the exterior of the unit. Water eliminator/filters shall be provided. Simultaneous economizer/compressor operation is also possible Dampers shall fully close on power loss. Information is subject to change without notice Check local codes Printed 04/26/2021 ® York® Sun TM Pro 3-12.5 Ton Page: 12 W YORK Package Single Package R-41 OA Air Conditioner Project Name: 19981 -Mattituck,NY Unit Model# ZJ061N12D2B5GCA2R3 Quantity, 2 Tag#'RTU-2,3 System ZJ06lNl2D2B5GCA2R3 Seismic Certification Information is subject to change without notice Check local codes Printed 04/26/2021 MYORK® York® Sun TM Pro 3-12.5 Ton Page- 13 Package Single Package R-41 OA Air Conditioner Project Name 19981 -Mattituck,NY Unit Model# ZJ061N12D2B5GCA2R3 Quantity 2 Tag#,RTU-2,3 System, ZJ06lNl2D2B5GCA2R3 Seismic Certification Information is subject to change without notice Check local codes Printed 04/26/2021 WYORK® York® Sun TM Pro 3-12.5 Ton Page 14 Package Single Package R-41 OA Air Conditioner Project Name: 19981 -Mattituck,NY Unit Model# ZJ061 Nl2D2B5GCA2R3 Quantity 2 Tag#.RTU-2,3 System, ZJ06lNl2D2B5GCA2R3 Seismic Certification Information is subject to change without notice Check local codes Printed 04/26/2021 MYORK® York@ a7 Un TM Pro 3-12.5 Ton Page 15 Package Single Package R-41 OA Air Conditioner Project Name- 19981 -Mattituck,NY Unit Model# ZJ061 Nl2D2BSGCA2R3 Quantity 2 Tag# RTU-2,3 System- ZJ06lNl2D2BSGCA2R3 Seismic Certification Information is subject to change without notice Check local codes Printed 04/26/2021 York® Sun TM Pro 3-12.5 Ton Page:16 WYORK Package Single Package R-41 OA Air Conditioner w/Reheat Project Name: 19981 -Mattituck,NY Unit Model#: ZR061N12D2B4CCA1A2 Quantity: 1 Tag#:RTU-4 System- ZR061 N12D2B4CCA1A2 Cooling Performance Total gross capacity 59.6 MBH I «air Npvwti,, ,, Sensible gross capacity 474 MBH Total net capacity 55.1 MBH _ P Y Sensible net capacity 429 MBH Seasonal Efficiency(at ARI) 14.25 SEER Efficiency(at ARI) 1210 EER Ambient DB tem 922 °F Entering'DB temp. 78.4 °F `" ` ' Entering WB temp. 648 °F Leaving DB 53.3 °F LeavingWB temp53.3 °F Power Input(w/o blower) 4.09 kW Sound power 84 dB(A) Refrigerant Refrigerant type R-41 OA a* Sys1 11 lbs 10 oz Reheat Performance 5 Ton Total capacity 253 MBH Sensible capacity 43 MBH . York Sun Pro units are manufactured at an ISO 9001 registered facility and Ambient DB temp. 85 °F each rooftop is completely computer-run tested prior to shipment. Entering DB temp. 75 °F Unit Features Enteringtemp. 7 °F Leaving DBB temp. 72..7 °F . 120 MBH Input Aluminized Steel,Two Stage Gas Heat Leaving WB temp 627 °F • Full perimeter base rails with built In rigging capabilities Power Input(w/o blower) 3.30 kW • Unit Cabinet Constructed of Powder Painted Steel,Certified At 750 Hours Gallons of water per hour 240 al/hr Salt Spray Test(ASTM B-117 Standards) Gas Heating Performance • Scroll Compressors] Entering DB temp. 60 °F • Dry Bulb Low Leak Economizer w/Barometric Relief and Hoods(Bottom or Heating output capacity(Max) 96 MBH Horizontal End Return Only)with Economizer Fault Detection&Diagnostic Supply air 1750 CFM (Meets ASHRAE 90.1-2013, IECC 2015,California Title 24,AMCA 511). Heating input capacity(Max) 120 MBH . 2 HP High Static Belt Drive Blower Leaving DB temp 110.8 °F Air temp.rise 50.8 °F • Solid Core Liquid Line Filter Driers SSE 80.0 % • Unit Ships with 2"Throwaway Filters Stages 2 • Replacement Filters 4-(24"x 16") Unit accepts 2"or 4"wide filters. Supply Air Blower Performance • Powered Convenience Outlet(110 VAC/15 Amp) Supply air 1750 CFM • Single Point Power Connection Ext.static pressure 1.88 IWG • Short Circuit Current:5kA RMS Symmetrical Add[.Unit Losses(Options/Accessories) 012 IWG . Through-the-Curb and Through-the-Base Utility Connections Blower speed 1219 RPM . Dirty Filter Switch Max BHP of Motor(including service factor) 2.30 HP Duct location Bottom Micro-Channel"all-aluminum"condenser coil,Copper tube/aluminum fin Motor rating 2.00 HP evaporator coil Actual required BHP 1.43 HP • Composite Drain Pan-Front Connection Power input 1.33 kW . Tool-free maintenance with features like hinged doors for all-access panels, Elevation 30 ft. slide-out blower and blower motor tray Drive type BELT Requires field-supplied drive true Standard Unit Controller: Smart Equipment Control Board Outside/Mixed Air Safety Monitoring-Monitors the High and Low-Pressure Switches,the Outside Air Cfm 350 CFM Freezestats,the Gas Valve,if Applicable,and the Temperature Limit Switch Outside Air DB temp 92.2 °F on Gas and Electric Heat Units.The Unit Control Board will Alarm on Ignition Outsided Air WB temp 744 °F Failures,Safety Lockouts and Repeated Limit Switch Trips. Outside Air RH 43 9 % Warranty Return Air CFM 1400 CFM One(1)Year Limited Warranty on the Complete Unit Return Air DB temp 75 °F Return Air WB temp 62 °F Five(5)Year Warranty-Compressors and Electric Heater Elements Return Air RH 48.1 % Ten(10)Year Limited Warranty-Aluminized Steel Heat Exchanger Electrical Data Power supply 230-3-60 Unit min circuit ampacity 409 Amps Unit max over-current protection 50 Amps Dimensions &Weight Hgt 42 in. Len 89 in. Wth 59 in. Weight with factory installed options 1052 lbs Clearances Right 12 in Front 36 in Rear 36 in. To p 72 in. Bottom 0 in Left 36 in Note Please refer to the tech guide for listed maximum static pressures Information is subject to change without notice Check local codes Printed 04/26/2021 York® Sun TM Pro 3-12.5 Ton Page. 17 MYORK Package Single Package R-41 OA Air Conditioner w/Reheat Project Name: 19981 -Mattituck,NY Unit Model#, ZR061 NUMMCCA1A2 Quantity: 1 Tag#-RTU-4 System ZR061N12D2B4CCA1A2 '0 AMERICAN j� ,j ��® / +�\ QUALITY! "CAN t' uS.�.-. Information is subject to change without notice Check local codes. Printed 04/26/2021 ® York® Sun TM Pro 3-12.5 Ton Page 18 WYORK Package Single Package R-41 OA Air Conditioner w/Reheat Project Name- 19981 -Mattituck,NY Unit Model# ZR061 N12D2B4CCA1A2 Quantity 1 Tag#•RTU-4 System* ZR061N12D2B4CCA1A2 Factory Installed Options ZR061 NIMB4CCAM2 Equipment Options Option(s) Selected SIr> IbTackage'd R-411dA-'Air Conditioner,,:Standard �$`� �:j„i' '\,' ��°R ✓`,4". �.. "\^tis ' "` 't - "t�,/: ,t,- t� '.✓s.^;`,�¢�f,`, auk '`m ;a �: �' ` '� .,.`��? - ' k, 'yyr 'Product�Ctegory: ZR ��.' " ;a e` `MagnaDry wit .teheat as; >_ Nominal Cooling Capacity: 061 5 Ton ,` „°.,, \ TwO$ta a 5Ex °p h M[i�eat Tjrpe and2'.Notn'ft0Heat Cdpacify �;n112 120 MB,H�fiiput Aluminized^''Steep" g F eat �. ::���;x��i.`� w��;;,� .-.. ,a Blower Option: D HP High Static Belt Drive Blower ?n 1(oltage: 2 208/2'30-3 60 Dry Bulb Low Leak Economizer w/Barometric Relief and Hoods(Bottom or Horizontal End Return Only)with Outside Air Option: B Economizer Fault Detection & Diagnostic(Meets ASHRAE 90 1-2013, IECC 2015, California Title 24, AMCA 511). * �..�- r„ gy'j. a�., Yac x £rVice\��?tlOr15;^ 4` � Powered'Convenietce0utlet"{110 VAC/15 Amp) . ' Sensor Options: C Dirty Filter Switch x e 'I'M E `;s 4 �'�,. �„�.�, _ ny" ,'\\; s rox,at.,`a-rP�«,q 'ar ,..". `�.�...."...�XW",��"„",» "< r" ' ' ;' ,` 'S'rri'i tt E uiprrie it Coritroiier fnGluding i�isc a ge Air, may` -!F' r5'�,jwp`@.��` " + �z`r .-.�� \9.di-.. �� �,,.�3'„� "t '�<�:� �` 3 .,;ar', �u�"%�4 Via,. � ����_�;... � �,' ��� `�" .'` r ,Ak6 -,Air, iWOu0,66r'Air Temperat4te.Sensors. •, ems- {'rOntC4tS: ` �,r` `, z,_` \\ z - "a 'y AC et SfTP,MQtlbu"s a d Communication Ca " 'moi' : .= BAGM nd,X12rtl:f' Refrigeration: A Micro-Channel "all-aluminum"condenser coil, Copper tube/aluminum fin evaporator coil -:ate. �c g«' g,`a «. �,V" „W'a` �,r•...." "i�< ru,r> ; I Ad rtional Optic `s•' ' , Standard 2.Throwawaya'Fittiers % ." ".fie .fix," , a' __. .: gw = :` M'. ,. ` . .d_ __,._. � ,"",,,,: , " . Cabinet Options: A Composite Drain Pan-Front Connection ._, TT '; `m ^" Proiduct!Gene'ation: f A6 Field Installed Accessories O 1 BD0408- Burglar Bars (32.0 lbs) O 1 FE0412- Flue Exhaust O 1 HA0450- High Altitude Kit for O 1 CG0428- Coil Guard (20.0 lbs) Extension Kit (14.0 lbs) Natural Gas (1.0 lbs) O 1 CV0402- Concentric O 1 FF0415-2" Only metal Filter O 1 HA0452- High Altitude Kit for Diffuser,Flush Mount,18RD Frame Kit(16.0 lbs) Propane (1.0 lbs) O 1 CV0411 -Concentric O 1 GP0405 - Gas Piping Kit for O 1 HG0415- Hail Guard Kit- Diffuser,Side Discharge,1 8RD Bottom Gas Supply Connection Diamond Pattern (50.0 lbs) (55.0 lbs) with External Shut-Off(includes: O 1 HG0431 - Hail Guard Kit- ( 1 CV0419- Concentric Internal gas pipe, fittings, gas cock Provent Style (20.0 lbs) Diffuser,Specialty,18X18 & panel gaskets) (10.0 lbs) O 1 LN0407- Low NOx Kit Information is subject to change without notice Check local codes Printed 04/26/2021 ® York® Sun TM Pro 3-12.5 Ton Page 19 2YORK Package Single Package R-410A Air Conditioner w/Reheat Project Name, 19981 -Mattituck,NY Unit Model# ZR061 NIMB4CCAlA2 Quantity. 1 Tag#:RTU-4 System: ZR061NUMMCCA1A2 O 1 NP0460- Natural Gas to O S1-03102529006 - Non- O S1-NSB8BHN143-0 -Wall Propane Conversion Kit(2.0 lbs) Networking Wall Sensor with Temperature and 3% Relative O 1 RC0470 - Roof Curb- 8" High, Setpoint Adjustment and Over-ride Humidity Combined Sensor, Flat, Uninsulated, Full Perimeter Button-Allows remote sensing Warmer/Cooler Display, BLACK, (Shipped Knocked Down) (135.0 and control from single or multiple NO JCI LOGO, NS8000 Series lbs) zones. Allows setpoint to be (0.4 lbs) O 1RC0471 - Roof Curb- 14" High, adjusted ±5° F. Override allows O S1-NSB8BHN240-0 -Wall Flat, Uninsulated, Full Perimeter setpoint to be overridden for 2 Temperature and 3% Relative (Shipped Knocked Down) (135.0 hour time period. (0.2 lbs) Humidity Combined Sensor, Full lbs) O S1-ADDWIRE-Add-a-Wire allows Display, WHITE, JCI LOGO, O 1 RC0476- Roof Curb-24" High, 5-wire thermostats to use only 4 NS8000 Series (0.4 lbs) Flat, Uninsulated, Full Perimeter wires. (0.3 lbs) O S1-NSB8BHN241-0 -Wall (Shipped Knocked Down) (135.0 O S1-CTSDTS-CTS Wired Temperature and 3% Relative lbs) Temperature Sensor for Humidity Combined Sensor, Full O 1 WC0412-Wooden Crate (445.0 thermostat I Duct*Also works for Display, WHITE, NO JCI LOGO, lbs) LX Series (0.3 lbs) NS8000 Series (0.4 lbs) O 2AP0402 -Air Proving Switch (1.0 O S1-CTSHTS -CTS Hardwired O S1-NSB8BHN243-0 -Wall lbs) Temperature Sensor for CTS Temperature and 3% Relative O 2AQ04700524-CO2 Space Thermostats*Works with LX Humidity Combined Sensor, Full Sensor:Wall Mount Accessory series as well (0.2 lbs) Display, BLACK, NO JCI LOGO, (5.0 lbs) O S1-CTSPLATE -Wall Plate for NS8000 Series (0.4 lbs) O 2AQ04700624-CO2 Unit Mount CTS Thermostats*Also works for O S1-NSB8BPN240-0-Wall Accessory(4.6 lbs) new platform LX series models Temperature and 2% Relative O 2ECO401 - Kit, Single Enthalpy below(0.0 lbs) Humidity Combined Sensor, Full Field Installed (1.0 lbs) O S1-CTSWFTS - CTS Temperature Display, WHITE, JCI LOGO, •2ECO402 - Kit, Dual Enthalpy Sensor with WiFi for CTS NS8000 Series (0.4 lbs) Field Installed (Includes two Thermostats *Also works with LX O S1-NSB8BPN241-0-Wall humidity sensors) (1.0 lbs) Series (0.1 lbs) Temperature and 2% Relative O 2PE04704706- Power Exhaust O S1-LXLOCK- Locking Ring For Humidity Combined Sensor, Full 230V without Baro Relief LX-Series Thermostats (0.4 lbs) Display, WHITE, NO JCI LOGO, Downflow or Horizontal (19.0 lbs) O S1-LXPLATE-Wall Plate For LX- NS8000 Series (0.4 lbs) • 2SDO4700824- Smoke Detector Series Thermostats (0.0 lbs) O S1-NSB8BPN243-0-Wall Kit w/ Mounting Hardware for O S1-LXWFM - For LX Series Temperature and 2% Relative Supply Air(Horizontal/Downflow) Thermostats -WiFi Humidity Combined Sensor, Full Only (9.4 lbs) Communication (1.0 lbs) Display, BLACK, NO JCI LOGO, O 2SDO4700924-Smoke Detector O S1-MP-PRTKIT-0P- MAP NS8000 Series (0.4 lbs) Kit w/ Mounting Hardware for (Multiple Access Portal) Gateway O S1-NSB8BTN041-0'-Wall Return Air(Downflow Only) Only Kit- Replacement MAP gateway Temperature Sensor, No Display, (10.0 lbs) protective case, lanyard and WHITE, NO JCI LOGO, NS8000 O 2SD04701024- Smoke Detector communication cable. Use only to Series (0.4 lbs) Kit w/Mounting Hardware for replace worn or damaged O S1-NSB8BTN043-0-Wall Supply (Horizontal/Downflow) and components. (0.3 lbs) Temperature Sensor, No Display, Return Air(Downflow Only) (8.0 O S1-NSB8BHN041-0 -Wall BLACK, NO JCI LOGO, NS8000 lbs) Temperature and 3% Relative Series (0.4 lbs) O S1-02812496000- Blower Sheave Humidity Combined Sensor, No O S1-NSB8BTN141-0-Wall AK79 Field Installed Drive (4.0 lbs) Display, WHITE, NO JCI LOGO, Temperature Sensor, O S1-03102529000 - Non- NS8000 Series (0.4 lbs) Warmer/Cooler Display, WHITE, Networking Wall Sensor-Allows O S1-NSB8BHN043-0 -Wall NO JCI LOGO, NS8000 Series remote sensing and control from Temperature and 3% Relative (0.4 lbs) single or multiple zones. (0.2 lbs) Humidity Combined Sensor, No O S1-NSB8BTN143-0-Wall O S1-03102529004- Non- Display, BLACK, NO JCI LOGO, Temperature Sensor, Networking Wall Sensor with NS8000 Series (0.4 lbs) Warmer/Cooler Display, BLACK, Over-ride button-Allows remote O S1-NSB8BHN141-0 -Wall NO JCI LOGO, NS8000 Series sensing and control from single or Temperature and 3% Relative (0.4 lbs) multiple zones. Override allows Humidity Combined Sensor, O S1-NSB8BTN240-0 -Wall setpoint to be overridden for 2 Warmer/Cooler Display, WHITE, Temperature Sensor, Full Display, hour time period. (0.2 lbs) NO JCI LOGO, NS8000 Series WHITE, JCI LOGO, NS8000 (0.4 lbs) Series (0.4 lbs) Information is subject to change without notice Check local codes Printed 04/26/2021 ® York® Sun TM Pro 3-12.5 Ton Page-20 WYORK Package Single Package R-41 OA Air Conditioner w/Reheat Project Name: 19981 -Mattituck,NY Unit Model# ZR061N12D2134CCA1A2 Quantity 1 Tag#:RTU-4 System ZR061IN12D2134CCAIIA2 O S1-NSB8BTN241-0-Wall O S1-TEC3013-16-000 -7 DAY O S1-TEC3031-16-000- 7 DAY Temperature Sensor, Full Display, PROGRAMMABLE PROGRAMMABLE WHITE, NO JCI LOGO, NS8000 THERMOSTAT, ZIGBEE PRO THERMOSTAT, ZIGBEE PRO Series (0.4 lbs) WIRELESS COMMUNICATION, WIRELESS COMMUNICATION, O S1-NSB8BTN243-0-Wall FCUNAV, ON/OFF OR RTU/HEAT PUMP WITH ECON, Temperature Sensor, Full Display, FLOATING, OCC & DEHUMID, OCC SENSOR, FULL COLOR, BLACK, NO JCI LOGO, NS8000 FULL COLOR, WHITE, NO LOGO WHITE, NO LOGO (0.8 lbs) Series (0.4 lbs) (0.8 lbs) O S1-TEC3612-14-000- 7 DAY O S1-TBPU435-Y-York Branded O S 1-TEC3022-14-000-7 DAY PROGRAMMABLE CTS Series 13/4 Stage Heating 2 PROGRAMMABLE THERMOSTAT, OPTIONAL MSTP Stage Cooling (5+1+1) 7-day THERMOSTAT, ZIGBEE PRO OR N2 COMMUNICATION, Programmable WiFi On-Board WIRELESS COMMUNICATION, FCU/VAV, ON/OFF OR (1.2 lbs) FCUNAV, 0-10VDC PROP, FLOATING, DEHUMID, FULL O S1-TBPU436-Y-York Branded DEHUMID, FULL COLOR, COLOR, WHITE, JCI LOGO (0.8 CTS Series 13/4 Stage Heating 2 WHITE, JCI LOGO (0.8 lbs) lbs) Stage Cooling 1 (5+1+1) 7-day O S1-TEC3022-16-000-7 DAY O S1-TEC3612-16-000- 7 DAY Programmable I WiFi and PROGRAMMABLE PROGRAMMABLE Humidity On-Board (1.2 lbs) THERMOSTAT, ZIGBEE PRO THERMOSTAT, OPTIONAL MSTP O S1-TBSU232-Y-York Branded LX WIRELESS COMMUNICATION, OR N2 COMMUNICATION, Series 12.3" Display 12 Stage FCUNAV, 0-10VDC PROP, FCUNAV, ON/OFF OR Heating 12 Stage Cooling 17-day DEHUMID, FULL COLOR, FLOATING, DEHUMID, FULL Programmable (0.2 lbs) WHITE, NO LOGO (0.8 lbs) COLOR, WHITE, NO LOGO (1.0 O S1-TBSU304-Y-York Branded LX O S 1-TEC3023-14-000 -7 DAY lbs) Series 13" Display 12 Stage PROGRAMMABLE O S1-TEC3613-14-000- 7 DAY Heating 12 Stage Cooling I Non- THERMOSTAT, ZIGBEE PRO PROGRAMMABLE Programmable I Humidity On- WIRELESS COMMUNICATION, THERMOSTAT, OPTIONAL MSTP Board (1.0 lbs) FCUNAV, 0-10VDC PROP, OCC OR N2 COMMUNICATION, O S1-TBSU306-Y-York Branded LX & DEHUMID, FULL COLOR, FCUNAV, ON/OFF OR Series 13" Display 13/4 Stage WHITE, JCI LOGO (0.8 lbs) FLOATING, OCC & DEHUMID, Heating 12 Stage Cooling 1 O S 1-TEC3023-16-000 -7 DAY FULL COLOR, WHITE, JCI LOGO (5+1+1)7-day Programmable PROGRAMMABLE (0.8 lbs) Humidity On-Board (1.0 lbs) THERMOSTAT, ZIGBEE PRO O S1-TEC3613-16-000- 7 DAY O S1-TEC3012-14-000- 7 DAY WIRELESS COMMUNICATION, PROGRAMMABLE PROGRAMMABLE FCUNAV, 0-10VDC�PROP, OCC THERMOSTAT, OPTIONAL MSTP THERMOSTAT, ZIGBEE PRO & DEHUMID, FULL COLOR, OR N2 COMMUNICATION, WIRELESS COMMUNICATION, WHITE, NO LOGO (0.8 lbs) FCUNAV, ON/OFF OR FCU/VAV, ON/OFF OR O S1-TEC3030-14-000 -7 DAY FLOATING, OCC & DEHUMID, FLOATING, DEHUMID, FULL PROGRAMMABLE FULL COLOR, WHITE, NO LOGO COLOR, WHITE, JCI LOGO (0.8 THERMOSTAT, ZIGBEE PRO (0.8 lbs) lbs) WIRELESS COMMUNICATION, O S1-TEC3622-14-000 - 7 DAY O S1-TEC3012-16-000 -7 DAY RTU/HEAT PUMP WITH PROGRAMMABLE PROGRAMMABLE ECON,FULL COLOR, WHITE, JCI THERMOSTAT, OPTIONAL MSTP THERMOSTAT, ZIGBEE PRO LOGO (0.8 lbs) OR N2 COMMUNICATION, WIRELESS COMMUNICATION, O S1-TEC3030-16-000 -7 DAY FCUNAV, 0-10VDC PROP, FCU/VAV, ON/OFF OR PROGRAMMABLE DEHUMID, FULL COLOR, FLOATING, DEHUMID, FULL THERMOSTAT, ZIGBEE PRO WHITE, JCI LOGO (0.8 lbs) COLOR, WHITE, NO LOGO (0.8 WIRELESS COMMUNICATION, O S1-TEC3622-16-000-7 DAY lbs) RTU/HEAT PUMP WITH ECON, PROGRAMMABLE O S1-TEC3013-14-000- 7 DAY AND FULL COLOR, WHITE, NO THERMOSTAT, OPTIONAL MSTP PROGRAMMABLE LOGO (0.8 lbs) OR N2 COMMUNICATION, THERMOSTAT, ZIGBEE PRO O S1-TEC3031-14-000 -7 DAY FCUNAV, 0-10VDC PROP, WIRELESS COMMUNICATION, PROGRAMMABLE DEHUMID, FULL COLOR, FCU/VAV, ON/OFF OR THERMOSTAT, ZIGBEE PRO WHITE, NO LOGO (0.8 lbs) FLOATING, OCC & DEHUMID, WIRELESS COMMUNICATION, FULL COLOR, WHITE, JCI LOGO RTU/HEAT PUMP WITH ECON, (0.8 lbs) OCC SENSOR, FULL COLOR, WHITE, JCI LOGO (0.8 lbs) Information is subject to change without notice Check local codes Printed 04/26/2021 ® York® Sun TM Pro 3-12.5 Ton Page-21 MYORK Package Single Package R-410A Air Conditioner w/Reheat Project Name: 19981 -Mattituck,NY Unit Model# ZR061 N12D2B4CCA1A2 Quantity: 1 Tag#•RTU-4 System- ZR061N12D2MCCA1A2 O S 1-TEC3623-14-000-7 DAY PROGRAMMABLE THERMOSTAT, OPTIONAL MSTP OR N2 COMMUNICATION, FCU/VAV, 0-1 OVDC PROP, OCC & DEHUMID, FULL COLOR, WHITE, JCI LOGO (0.8 lbs) O S1-TEC3623-16-000-7 DAY PROGRAMMABLE THERMOSTAT, OPTIONAL MSTP OR N2 COMMUNICATION, FCU/VAV, 0-10VDC PROP, OCC & DEHUMID, FULL COLOR, WHITE, NO LOGO (0.8 lbs) O S1-TEC3630-14-000- 7 DAY PROGRAMMABLE THERMOSTAT, OPTIONAL MSTP OR N2 COMMUNICATION, RTU/HEAT PUMP WITH ECON,FULL COLOR, WHITE, JCI LOGO (0.8 lbs) O S1-TEC3630-16-000- 7 DAY PROGRAMMABLE THERMOSTAT, OPTIONAL MSTP OR N2 COMMUNICATION, RTU/HEAT PUMP WITH ECON,FULL COLOR, WHITE, NO LOGO (0.8 lbs) O S1-TEC3631-14-000- 7 DAY PROGRAMMABLE THERMOSTAT, OPTIONAL MSTP OR N2 COMMUNICATION, RTU/HEAT PUMP WITH ECON, OCC SENSOR, FULL COLOR, WHITE, JCI LOGO (0.8 lbs) O S 1-TEC3631-16-000-7 DAY PROGRAMMABLE THERMOSTAT, OPTIONAL MSTP OR N2 COMMUNICATION, RTU/HEAT PUMP WITH ECON, OCC SENSOR, FULL COLOR, WHITE, NO LOGO (0.8 lbs) O S 1-YK-MAP 1810-OP- MAP (Multiple Access Portal) Gateway- For use with SimplicitySE Control. (0.2 lbs) O S1-YK-MAP1810-OS -Stationary MAP Gateway(Includes MAP Gateway, Field Bus Adapter, Mounting Bracket and 100 to 240 VAC Power Supply). US- compatible counties. (1.9 lbs) Information is subject to change without notice Check local codes Printed 04/26/2021 YorkO Sun TM Pro 3-12.5 Ton Package Page:22 YORK Single Package R-41 OA Air Conditioner w/Reheat Project Name: 19981 -Mattituck,NY Unit Model# ZR061N12D2134CCAlA2 Quantity 1 Tag#:RTU-4 System ZR061N12D2134CCA1A2 Consolidated Drawing r- --- ---- - --- - -- -- ---- - - - - --------- - --- - -- ---- - --- --- -- -- -- - - --------- iI 2 3 4 S 6 7 8 9 10 II12 13 14 15 `6 j NOTES n cYERunIG ' CENTEP Dr[Fault 1 I COR OUTDOOR JSF ONI Y TONNAGE I Wk IGn (1651`_. All ON;3f S£JN- <PO=8_COPAER LOADS IEeS>(BASE UNIT) 1 2 Vii IGFIS SHOWN Ai,E EOR COOLING ONLY UNITS 7 (EASE UNIT) I d t - A P C _-D R 3 MIN, C_ 2l tARANCLS TO BL 2 6 5 /LS 66C [390 38 [60 (965,21 24 9,61 20C(91, 149,68- 21A[94) 241 11-331-_ N RIGHT SIDE 12 [3051 2 68 1 1 7 S irrIS 88C 1399; 1 38 1965 21 24 t6C9,61 205 1931 11.3 t691 223[.01 Z99 11361 !EFTSIDE '6 (9151 [830,01 ' I 64 5 7it2U 8 13-13-4 171 761610.1 21C[95, I,1 1781 21;(991 766 11211 CRONT 36 [9151 6 83 - - RE1,R 36 [9151 ;113,51 6-3& i 5 117717 913 r413: 1 38;965 11 74 T6C9 61 712 1961 158'77? 730[ICN 339 11401 TOP. 72 11830-- �5 IJ/i'4TIC 1349 + w(1016]�Z4 JtfiC9,61 72(Tel 14s ,6e+ -d05[931 ?s nisi I BOT-OM 0 (0) 24 38 r 1 23/13 886 1399: 40[10163 76 Ec6C,41 214 197: 1'4 1791 221 Poo; 27 11231 i 4 TO RENOVE TFE S_IOE-OUT DRAIN PAIN, A REAR CLEARANC'- OE 1619,21 I Z4r24 868[394; 40(10161 25[616,41 211 1961 142'78. 21e(393 261 Tlzil 60 11 t 152[ mr1 IS REOLIRED IF SPACt IS UNAVAILAB_L, `TIE � ZD15 957(435: !fi;965 21 ?3[514_2] 7u [47. 6( 173' 2<9[ 131 33:(1511 ',RAIN ?!,h CAN 6E RFNOYFG iH'OJG=i -HE FRONT BY SEPAit,T'NG k - ''- - -;-:- - - ----THE CORNER WALL, ^18 00 3 i 83 7 a 1A72R 965[439•_ �8 1965,71 23(584,?1 _?IE�[98I� 161 173, -251 -33T €457,71 I f[94,3] 3 2i/11 -922 [31sT 4z4 n6 1 z4 v[62 41 202[011 - 84 38<' ?55 f 16 28-(128] 5 COR SVA,IFR SERVICE AND OPFKAT,GkA( CLEARANCES ----- ----_---==m_----_'- -- ___-- _-- _-_-_---_--- -- CONTACT YOUR APPLICATION ENC,hEER'NG DEPARTMENT 32 06 3 6,82 4 2TIZ4 95C [436: 42 5[10'19.5' 25 5 1617,'1 217. 198; tee(90, 260 1 18' 265[t291 6 DOWNFLON DUCTS DESIGNED 10 BE ,,,,rTACNED TO ACCESSORY 18 E,4; i 173,3' 5 21111 966[439_�41 6(1056 6_-25 5(6,47,71 223(1011 196 E89i 257 tli'1; 293[1331 ROOF C RB ON-f IF UNIT IS MO.;NTFD SIDE SUPPLY, I' p - N H I 1S RLCOvMENDED THA) THE DU FS ARE SU?POP,TED BY Y _ B 5 CROSS BPACLS, AS DARE OR ACCESSORY R001 CJP,BS ------- - --- - 1265,9] =463,6] 7 SIDE OsCT CtANGES ARE C 75 FEGd 26 10 � � S; � � ' c 1 1 U. 1 ALTERNATE CONDENSATIO`, OP,AIIJ BOTTOM DLCT. GO NOT HAVE FLANGES -567,9]� I 8 MINIMJM CONDENSATIO11 TRAP REIGHT S,A,L B£ 1 5 TIMES (CPCM NTG 1 P7 5C '24 00 s l TFL LOWEST NEGATIVE STATIC FLA11r Ji698,511 €609,61 ' R 9 DIMENSIONS IN T l ARE IN NILL`VLTERS OR ,ILOGRAMS �_ R f„ j 10 OPT]"vNhi C,OI, GJARDS, PO@ER FXHAL`ST, GAS NEAT, LEFT ' - __, •i' - " I0 00 T 27 75 'CONONIZER, DISCONNECT S7,I1CP, CONVENIENCE OU1LL1, N _ ! I • s (704,9] I [406,41 J AND dAROMETITIC 11008 ;RESP AIR: r'OODS SH01WN - i -(� R1t9FtT R II DEL[-£O T = cUPPLY y 2 8 TUBE HEAT EXCHANGER IS NOT AVAILA6LE 7C 39 F- COR 3 i 4 TON UNITS 'S18.0< ?511,151 t486.2i [ id i Y 21 00 o _ rh �• `~; - 12406 (4„y5,41 , 1533,4: "l 306,31 _ --_ C 10- .DIRECTION OF A RF-OW _F 3 F ' I4 47 FRONT BOTTOM GAS I-5 6 Y D r Y 5 f7 5 - 31 69 CENTER OF SRAV,7 136,,61 SU,PsY NTR 'fJ2 00 0,8] -131,I1 C4I6941 \-BOTTOM ENTRY 1698,51 [604,91 i ( 5808: P07(ER 02 SO •63,53 REAR IPARIIAL VIEWI 18 89 CONTR01 3X 00 875 122 731 (INTAKE HOOD NOT SHOt1N IN TF S VIEW) F i OUTSIDE h R- DISCONNECT SWITCH COVER- - -•779,91 E � ,N?AKT HOOD tOPTIONAII -X TOP VIEW (OP•IONAI 'OWEh EN-RY 0 2 50 (63.5S8 09 -{ 88 7C I 11475.51 i FRESH NIR HOOD." `.224`'4' = LCONOMILLR (OPTIONAL s _ 1;R; BLOWER ACCESS AS IhL>T __ 0 IT, 'A&'I• C0?r'11p/ -- - D 75 12 I -COMP?ESSOR 7 -'� [553,3; € AECCSS CONTROL ENTRY 00 8,5 [22,21-�` ACCESS _ - - POWER CNTR° 07 50 163.5'----_- 4t061,6i ` PAROM;TRt'C dEL I EC HOOD T ----- -7 - ac----I I as iia C -CWEdC)HAUST T IE 38 LEFT VIEW OP-EONhI) 27 31 i 1 !25318129,- 21 9 [289, t I] [--SFE R'EThI[ A FOR Imo-538,21 --- -- 59 00 - - --� CONVLNIENCE OUT-ET CDJLR DRAIN ,.00E-ION EXHAUST f1498,61 314° 1.-1- _ (OPT'ONAL) '-CO;L GUARD 89.00 RIGHT VIEW ,OPTIONAL) 8 CONVENIENCE OLTLET .2260,6; FRONT VIEW P0*FR ENTRY 00 8'S €2`[,231 IOPTION:IL FRONT CO GUARD NOT SHCWN ,K THIS VIEW) 1 5 32 , ?V DATE REV SICK RECORD EC NO OR CN 1ENG TNIPC W.e FiDJECTIO 411e3 4 wA1T(C R10 N PC'.JCL tN 1 PS MCi INT i0l[UR tOA i AI CCR 91�SC�3 ARf Cf IkD NO Till'9R17 0 SAi'ii TA3$i•C$FLA Af D2-11-2D h;4 GRAM NG (FAO(4 IST-PR D-2CCr42 ) - - - -- 75768_37(a;ti€SAA _ I+roxuRTroR.row,T TO C vE0.5 F 1X04_Y91•[CV 1[tt11C 0 C_CV__N_RS A_ i 1 , 3RA41 tl'u PFA rSNe T'i tt 5--_,DCY XATF0.1A • � �atc,Rc:s ctst4l o•r11r ,F:aT=(4 SJBMI;TAE DWG PRO DTP: N0. Ay PLIC1ABLE l C 136 sr; NGT AP 'ICAB!c A _R ONE Pt6CC HOW t STI FLAT C1. 2 ODE 4"c" CAB l �1�A OP? t >F(II[D 3:I'2i To Pt.a 0:C1µ1.- } .3 917[ A c4a F 9A.eA. r I•?4 I11PEt PIACI 9TWA Y o0 10T1NSON CONTROI S cA6 No Rev SCAI E 300 RYG 5 gltNm 171 7) Na::s R r 5883 183 A JhITA?•AROOUC75 GROJP n NTC11[1 RiI:NS APT iR 1Ti7C1 PART AO ' SCAL6 G CDS_ - �0 ROT SCiIF PFIF7 NCD NAY Or 73G59 S IT Nr E Cr t --- -I ---- - 7 - _--- --- -- - - 5 6 7 8 9 10 11 ? 13 14 13 16 Information Is subject to change without notice Check local codes. Printed 04/26/2021 ® York® Sun TM Pro 3-12.5 Ton Page 23 OYORK Package Single Package R-410A Air Conditioner w/Reheat Project Name 19981 -Mattituck,NY, Unit Model# ZR061N12D2B4CCA1A2 Quantity: 1 Tag#.RTU-4 System: ZR061N12D2B4CCA1A2 Component Locations Component Location Cooling With Gas Heat(3 Through 5 Ton) Filter drier(solid core) Disconnect location Filter access 3-5 Ton Reheat (optional disconnect switch) (2"or 4" Micro-Channel Aluminum Smart Equipment Control board w/ filter options) Tube/Aluminum Fin screw connectors for T-stat Condenser wiring and Network (single orifice System shown See Actual Model Physical Data for details) Connections w F Slide out motor and blower assembly for easy adjustment Second model nameplate ;•`,", and service inside hinged access 9w a.hr, x. Filter drier(solid core) panel k:3 '`w' '"" 3-5 Ton Cooling Base rails w/ Belt-drive blower s forklift slot �� � S. motor (three sides) ; and lifting °.,t" ,' ,rP� Power ventor holes . ,,a 3, w' '"' .r motor Roof curbs in eight-and20-gauge aluminized fourteen-inch heights n steel tubular heat Roof curbs for transitioning wa exchanger for long life from York SunlineT" footprint (stainless steel option) to the ZH/ZJ/ZR ZU/ZW/ZK Series footprint are available Side entryower One or Two stage gas heating to (field-installed accessory) p maintain warm,comfortable and control wiring temperature knockouts Slide-out drain pan Compressor access(high- with 1"NPT Intelligent control board efficiency compressor) connection for safe and efficient Toolless door operation latch Information is subject to change without notice Check local codes Printed 04/26/2021 ® York® Sun TM Pro 3-12.5 Ton Page:24 MYORK Package Single Package R-41 OA Air Conditioner w/Reheat Project Name: 19981 -Mattituck,NY Unit Model# ZR061 N12D2B4CCA1A2 Quantity: 1 Tag#:RTU-4 System: ZR0611412MMCCA1A2 Low Leak Downflow Economizer Low Leak Downflow Economizer,(shown with optional Power Exhaust) i I I Fresh Air Hood (included) in Low Leak Economizer(included) ' �- Power Exhaust (optional) Barometric Relief Damper Barometric Relief (included) Hood (included) Low leak economizers are capable achieving low leakage rates of'3 cfm/sq. ft at 1" of-static pressure, meeting or exceeding the following standards: ASHRAE 90 1-2010 ASHRAE 62 AMCA 51.1 (licensed as Class 1A damper) International Energy Conservation Code (IECC) California Title 24 The outdoor intake opening shall be covered with a rain hood that matches the exterior of the.unit. Water eliminator/filters shall be provided. Simultaneous economizer/comp"ressor operation is also possible. Dampers shall fully close on power loss. Information is subject to change without notice Check local codes Printed 04/26/2021 13YOR ® York® Sun TM Pro 3-12.5 Ton Page.25 KPackage Single Package R-410A Air Conditioner w/Reheat Project Name, 19981 -Mattituck,NY Unit Model* ZR061 N12D2MCCAlA2 Quantity: 1 Tag#.RTU-4 System: ZR061N12D2B4CCA1A2 Typical Wiring Diagram 3-5 Ton Re-Heat A B C D E F G N I J A L SECONDARY 052 ��---GGpp f(HI POWER SUPPLY3360 ELEMENTARY DIAGRAM COOL ING UNIT WITH GAS WITH H G R POKER SUPPLY (} �DI1� i LX-BLA 2 USE2 COPPER 0 321PR---- I LfGfXD 120 160Y _ \ [SFE NOTE SI CONDUCTORS RNP PO1EX110NRFifA,REMOTE MINIMUM USE COPPER 111 ALS SIITCX,AUI LIMIT POSITION 0 1000 OHMS IOP110NAL1 COXOUCi0R5 (�09 IBA ONLI �V 13318A- I P266 CONOfNSfR CB CIRCUIT BAEAKELIK6A 7 2 AMP NOS SNITCH,ROLLOUT ONLY _ \ OUTLET n n FAH fOtlIROL CCH(CRI RELAY,CRANKCASFONEAIERIISEE NOT[SI SORA SFNSON,FDETIITITECTOR :tlSIR01R1[:RELER fURX0AIR110PI10NIL1 120,CIPPIRIENCF OUTLET IOPTIONALI_ LJ�1 11110, I N2 NI LI L21N DAS SENSOR,DISCHARGE AIR IOP110NAU $OSA SENSOR,OFifCiOR,SHONE.SU LT AIR:0 ON 12JIPR _ \ I I DFS 1I1TCN,D11R1Y AIR FILTER(OPTIONAL( 11 PA. iSYA,21V 12llPN TBI ON N0109,DRAFT USA UNI1 SHUTDOWN RELAY(OPTIONAL FOR SPECIFIC BAS UNITS) NJ I OSI SWITCH,DISCONNECT PAIN WN WIRE NOT,REMOTE NIX POSITION CONNECTIONS II 3811'8 I IO11PR NI I ISIIBK CONPflAI OSI SWITCH,DISCONNECT FOR 120V GFCI S11P3 SOCKET PLUG CONNECTION,211 GAS HIAT IONi IBIBX �" I ICIIBM FCR RELAY,ECONOMIZER CONTROL IOP $SIPS SOCNEIIPGUG To [C PRESSURES B LINE TEMP __ _ FNI NDIOR,OUTDOOR FAX 511P1 SOCKETIPLUG 111,CT 1.1:211111,SECTION N 1301PR I I kl 2 l 15211 p FN2 MOTOR,OUTDOOR FAN(OPIIOXAII 5121PI2 SIM'ETIPlUG COA.ICTION,EINE VOLTAGE P01[ft EIHAUSI 7 1191BR 11110 IT - FSI THERNOSIAI,LOW EVAP I[RP SI3IP13 SOCAEi1PLUfi CONXfC110N,21Y SNORE DEifC10p RETURN AIA N3 r2 ,1281 I -- - NI J 15311 10218E 3nGAS VALVE SIIIPII $DCRE11PlUG fONNEfiION,21V SNORE O[ifC1OR SUIPLI AIR 1221 NPI SWITCH,HIGH PRESSURE 5191PI9 SOCXEIIPGUG CONNE(110N,211 6 GINE VOLTAGE ECONIPOVER ETNAUSI II011--� 1211 (091 I - 1031T ICCONTROL,IGNITION GAS HEAT 52BIP28SofAEIIPLUG CONNECTION,NVSNOAEDETECTOR _ / ----^ FNI IFR RELAY,INDOOR(AN —FACTORY HIRING AND DEVICES ORLK BA TR MOTOR,INDOOR --•-OPTIONAL WIRING AND DEVICES$11111tH,lON PRESSURE FIELD WIRING 261Pf-1HT N I I IAS S1111CR,IOW AMBIENT IOPT104) ®IDENIFIED TLRAINAL ON RUN CAPACITOR Lp I^' LS 5WIT(N,LINII r.,VIE 13) i I R�110�111 ANBRNICONTACTOR,COMPRESSORS N3 fOXfACIOR,IANOR ROTOR 11 CONTACTOR,POWER EXHAUST IOPTIONALI 1361811 (OPTIOIAL) III - IOPIIO4ALI INE PH5 k0XITOR,PHASE LOSS[OPTIONAL) GY I r-1161Y-- L ILA PS 5111(X,PRESSURE INC O 33 NEG PHS BR RCI 3 CAPACITOR,RUX FAX MOTORS 228112351811 f !1!\ I I I ----TEL RB BOARD,RELAY CONTROL !Y t/ r n SDRA POA$OSA OXLI CO4NEC1 PIT TO'SENSOR I'ON SDC 2291Y C IldlBG I L-IIOIPR-III \ RC2 v IOP SON.L IDSA CONNECT P(d TO'SENSOR 2'ON 21v.f Opp I ---®j -bRN-- BP, u w u SDC L NO4 DIPP��1fSON SOC TO'2 SENSORS' 204IR h L--1411611- 1 Y R B 9 RED—I�I191R R0S P5 P$ PY2 SPARK = L__-14210-J 'S[NSOR I' 23019 l3 AIS 211IPR 232111 237141----, RN-2 211181 11 B2 ((ANE 2181010 SENSE FLAMESENSOR SDC 2A110-►f� 6 EO�1 .230161---------- = 512 PI2 !POWER EXHAUST OPIIONALI r-----'----251161 11110{7 519?IS BEN$ON Ip ISEE NOTE 9)OR 2' � �2271B1 BLN NS I� Ti p I 1Fl 1}2d11R (SEF NOTE 11 1111811{2--2)11 2571811 2081 NS 2 ftC)L �'/ °PEI SII $26 P28 I 2JOV PAI 114/PR I W[D 1 � /1.0 PHS-2 =1)2921BK-�I—BLK I (SEL ROTE 10) C n `-"- 1-�}L '}�`}I}- FD-2}2931R�2—RE S I --- 2181A OU PNS IY 2011A n(a TI Y TEMPERATURE CONTROLS r�2001R ---2591BR--- 0 3 2 AMP 21,SEC _ OPERATING 1ENPERANIE IIT-3 29111 3—IEL 5 Pl ll-H P 11 2311BR i5 VA = DEVICE, IDEG F'I A SS -I DDOOOOOB PJ -H�1 2381811 OPEN I CLOSE S7 21211 XI rl --{ - PS YEL 1}29SIY�1—YEL LPSI 1 xi I SII ALS 200 9 MAN ADS 300 14 PAN I i) 20511 P3 LAS 55 3 45 3 f21118A NV IFI NP12161 7 IHP51 I 1---�I 1-8621 CCR 8611811 2SSIBKHDAS PRESSURE CONTROLS G'ISIfiR 2171 4 I- SO 141_-� ISH NOTE Ill 2INK R 410 LA 5 I- SD 20)IA 241IBR DEVICE OPERATING PRESSURE(PSIG) (SI IFRI 2d21BP Sl pl IPL STANDARD ECONONIIER$ECT ION(NON BAST OPEN +1 (LOSE rl LK-1L_ --I I, BAN 1111 So 1SIIBL ALLATIVF I HPI 625 25 500 25 1 CRI I---- $2 \ + IS21PR r hUN1Olii LPI SO S 11 S p�i I I I I TEMP _20910T--{2 ci' GRA— GRA-TR "'SON i NOTES OUTDOOR — 2) 22618E 1 �7- j-- AIR [F EFI I I All FI[LD WIRING 10 BE A[CONPIISHEO FOLLOWING CITY,LOCAL AHDIOB p ITR FAN I "."A 1 PRP _ NAl10NAL CODE$IX E(FEC1 AT TIDE OF INSIALGAl104 OF THIS UVIL �3 �) X Sr ---I--pEUilYI I 1 CAUi ION LABEL ALL WINES PAIOA TO DISCONNECTION THEN SERVICING -c I TEL 620 I 1WDITYI I CONTROLS.HIRING ERRORS CAN CAUSE IMPROPER AND DANGEROUS TEMPCREATION IF ANY OF LRE?IRE,AS SUPPLIED WITH THE UNIT MUST BE R 1p 201lY�1�(i 1 + --' 1SfNSOR I RENOIED,11"IT BE RLPLAtfO WITH TYPE TOS DEGREE C,600 YOLT ISFF IIOI[81 816/YJ RETURN WIRE OR EQUIVALENT CLEARLY IT P'FOR IDENTIFICATION R --289111 OSNJ�6 IXl L- AIR-Ipl Sl VERIFY PROPER OPERATION AFTER SERVICING ISEE NOTE III 2 GRN --- 7 '1 A.PHASE MOTORS ARE INHERENTLY PROTECTED UNDER PRIMARY (PI YI $1 3 9 2251r51_ 1 8 A $FACTORY WIREDFOR CONDITIONS FOR 208V MOVE 12110 WIRE TO 208Y TERMINAL Y I ON 11 GI OAN p P1 11 BLA 9 S CRANKCASE HIAI[RS ARE 11T FOUND IN U91TS WITH SCROLL COMPRESSORS 1 12 I IO I 6 $FF UNIT HANEPLAIE FOR RAIINUR FUS[AXDIOR CIRCUIT BREAKER SIZE AND RININUP CIRCUIT ANPACITY OC( 17 10 319 PI9 I 1 SfI REHEAT DIAGRAM FOR THERMOSTAT CORRECTIONS, G ICON 111 11 OR4 YEL TEL 8 WNEX SIIIDIRI ECONOMIZER 15 INSTALLED REMOVE PLUG WITH JU11ER d ( TEL HIRES 8161P 1 NS i 9 IF MOKE 0[TECTORISI IS IAREI INSTALLED,REMOVE PLUGS)WITH RED ((pp�� BIN 3 BAN I 1U-'EPR WIRE TO `1B tOC1C I L-_------_ -------------- 10 WHEN PHASE LOSS MONITOR IS NOT INSTALLED WIRE 201IR IS CONNECTED SIRPLICIIY ( 10 PIN'SO'ON"'COX t90t BOARD[881 NF1►OAX G I I II IF 11511NOr IHS41110 TIRE 225 IR I$CONNECTED 10 PIN'R'ON THE FOR BAS UNITS 10X1101.BOARD 1111 56 _ IF RI L--_I SLI BAS COh1ROL5 SYSTEM 112 ►NLN RENOIE NINIXUN POSITION POTENTIOMETER IS INSTALLED, LASSO I0WP61 f_ ACCESSORY DIAGRAM REMOTE NINIMUREMOVE WIRE iPOSXT104 POORRECT IENIIONTEREDETAILHOWX IN (OPTIONAL( IAMB I IJ IC 111 AND GY RI TERMINALS ARE ONLY FOR 110 STAGE GAS HEAT DfS -BLU�2 I NOXI IF BAS DO X01 REMOVE JUMPER fOXXffi104 PT 14 EIc USED ON SOME BAS UNITS ISH BAS DIAGRAM)6 RDI USED 04 (}-1B R NON BA$UNIT$ LED ONT'STAT [SEE MOTE 121 CAUTION - OPEN ALL DISCONNECTS RNP © 21610 1215 BEFORE SERVICING THIS UNIT 245100 O 0 - 2161 REMOTE NINIXUN POSITION POTENTIOMETER DETAIL G 6 6 7 0 8 7 A REV A Information Is subject to change without notice.Check local codes Printed 04/26/2021 York@'Sun TM Pro 3-12.5 Ton Page*26 WYORK" Package Single Package R-410A Air Conditioner w/Reheat Project Name. 19981 -Mattituck,NY UnitModel# ZR061N12D2B4CCA1A2 Quantity: 1 Tag#.RTU-4 System ZR061N12D2B4CCA1A2 Seismic Certification rC -Z' A— :3 73' 4"' "'d ...... 41 1 11 IT,0- 4", 51 u v, 4 p" q n �Jln IV w" 411 4— Z -7 "W, Z T�e ...... Z' q' T- 7� -J, '7� -4, Information is subject to change without notice Check local codes Printed 04/26/2021 York® Sun TM Pro 3-12.5 Ton Page 27 YORK Package Single Package R-410A Air Conditioner w/Reheat Project Name. 19981 -Mattituck,NY Unit Model# ZR061 N12D2B4CCA1A2 Quantity. 1 Tag#.RTU-4 System ZR06lNl2D2B4CCA1A2 Seismic Certification ' 7-1 41 �<' -v `�.3«""___ `� " agµ ��.e .� y _-•<rRi'lwe y.r r. As,'s ' ..�5^ r r Information is subject to change without notice Check local codes Printed 04/26/2021 WYORK® York® Sun TM Pro 3-12.5 Ton Page:28 Package Single Package R-41 OA Air Conditioner w/Reheat Project Name. 19981 -Mattituck,NY Unit Model#. ZR061N12D2B4CCA1A2 Quantity 1 Tag#:RTU-4 System. ZR061N12D2B4CCA1A2 Seismic Certification Information is subject to change without notice.Check local codes Printed 04/26/2021 YWORK 0 York® Sun TM Pro 3-12.5 Ton Page 29 Package Single Package R-41 OA Air Conditioner w/Reheat Project Name: 19981 -Mattituck,NY Unit Model#• ZR061N12D2B4CCA1A2 Quantity: 1 Tag#.RTU-4 System, ZR061N12D2B4CCA1A2 Seismic Certification r a r , a Information is subject to change without notice Check local codes Printed 04/26/2021 Page 30 Date 04/26/2021 Project Name 19981 -Mattituck,NY Project Number Client/Purchaser Guide Specification Summary Page Product Series Models and Unit Tags kag 'or -,Rr"'3 jon,, ac 2B n, 4CCAIAZ. ' Information is subject to change without notice.Check local codes. Printed 04/26/2021 YORK® Guide Specification for Page:31 York® Sun TM Pro GENERAL removing panels or creating bypass of the coils. Condensate pan shall be slide out design, constructed of York®SunT"" Pro units are convertible single packages anon corrosive material, internally sloped and with a common footprint cabinet and common roof curb conforming to ASHRAE 62-B9 standards. Condensate for all 3 through 12-1/2 ton models.All 6-1/2 through 12- connection shall be a minimum of W I.D.female and be 1/2 ton have two compressors with independent R-41 OA rigid mount connection. refrigeration circuits to provide 2 stages of cooling. The units were designed for light commercial applications INDOOR (EVAPORATOR) FAN ASSEMBLY and can be easily installed on a roof curb, slab, or frame. All units are self contained and assembled on rigid full Fan shall be a belt drive assembly and include an perimeter base rails allowing for 3-way forklift access adjustable pitch motor pulley. Job site selected brake and overhead rigging. Every unit is completely charged horsepower shall not exceed the motors nameplate with R-41 OA, wired, piped, and tested at the factory to horsepower rating plus the service factor. Units shall be provide a quick and easy field installation. All units are designed to operate within the service factor. Fan wheel convertible between side and down airflow. Independent shall be double inlet type with forward curve blades, economizer designs are used on side and down dynamically balanced to operate smoothly throughout discharge applications, as well as all tonnage sizes. the entire range of operation. Airflow design shall be Predator®units are available in the following constant volume. Bearings shall be sealed and configurations: cooling only, cooling with electric heat, permanently lubricated for longer life and no cooling with gas heat, reheat only, reheat with electric maintenance. Entire blower assembly and motor shall be heat and reheat with gas heat. Electric heaters are slide out design. available as factory-installed options or field-installed OUTDOOR (CONDENSER) FAN ASSEMBLY accessories. DESCRIPTION The outdoor fans shall be of the direct drive type, discharge air vertically, have aluminum blades riveted to Units shall be factory assembled, single package, corrosion resistant steel spider brackets and shall be (Elec/Elec, Gas/Elec), designed for outdoor installation. dynamically balanced for smooth operation. The outdoor They shall have built in field convertible duct connections fan motors shall have permanently lubricated bearings for down discharge supply/return or horizontal discharge internally protected against overload conditions and supply/return and be available with factory installed staged independently. A cleaning window shall be options or field installed accessories. The units shall be provided on two sides of the units for coil cleaning. factory wired, piped and charged with R-41 OA refrigerant and factory tested prior to shipment. All unit wiring shall REFRIGERANT COMPONENTS be both numbered and color coded. The cooling Compressors: performance shall be rated in accordance with DOE and AHRI test procedures. Units shall be CSA certified to a. Shall be fully hermetic type, direct drive, internally ANSI Z21.47 and UL 1995/CAN/CSA No. 236-M90 protected with internal high-pressure relief and over standards. temperature protection. The hermetic motor shall be suction gas cooled and have a voltage range of+ or UNIT CABINET — 10% of the unit nameplate voltage. Unit cabinet shall be constructed of galvanized steel with b. Shall have internal spring isolation and sound exterior surfaces coated with a non-chalking, powder muffling to minimize vibration and noise, and be paint finish, certified at a 750-hour salt spray test per externally isolated on a dedicated, independent ASTM-B117 standards. Indoor blower sections shall be mounting. insulated with up to 1"thick insulation coated on the airside. Either aluminum foil faced or elastometric rubber Coils: insulation shall be used in the unit's compartments and be fastened to prevent insulation from entering the air stream. Cabinet doors shall be hinged with toolless access for easy servicing and maintenance. Full perimeter base rails shall be provided to assure reliable transit of equipment, overhead rigging, fork truck access and proper sealing on roof curb applications. Disposable 2"filters shall be furnished as standard and be accessible through hinged access door. Fan performance measuring ports shall be provided on the outside of the cabinet to allow accurate air measurements of evaporator fan performance without Information is subject to change without notice Check local codes Printed 04/26/2021 ® Guide Specification for Page 32 IMYORK York® Sun TM Pro a. Evaporator coils shall have aluminum plate fins GAS HEATING SECTION mechanically bonded to seamless internally enhanced Heat exchanger and exhaust system shall be copper tubes with all joints brazed. Special Phenolic constructed of aluminized steel, and be designed with coating shall be available as a factory option. induced draft combustion with post purge logic, energy b. Evaporator coils shall be of the direct expansion, draw- saving direct spark ignition, and redundant main gas thru design. valve. The heat exchanger shall be of the tubular type, c. Condenser coils shall have aluminum plate fins constructed of T1-40 aluminized steel for corrosion mechanically bonded to seamless internally enhanced resistance and allowing minimum mixed air entering copper tubes with all joints brazed or Micro-Channel temperature of 40 IF. Burners shall be of the in-shot aluminum tube, aluminum fins. type, constructed of aluminum-coated steel. All gas d. Condenser coils shall be of the draw-thru design. piping shall enter the unit cabinet at a single location, through either the side or bottom, without any field modifications. An integrated control board shall provide Refrigerant Circuit and Refrigerant Safety Components timed control of evaporator fan functioning and burner shall include: ignition. Heating section shall be provided with the a. Independent fixed-orifice or thermally operated following minimum protection: expansion devices. a. Primary and auxiliary high-temperature limit switches. b. Solid core filter drier/strainer to eliminate any moisture b. Induced draft pressure sensor. or foreign matter. c. Flame roll out switch (manual reset). c. Accessible service gage connections on both suction and discharge lines to charge, evacuate, and measure d. Flame proving controls. refrigerant pressure during any necessary servicing or e. All two stage gas units shall have two independent troubleshooting, without losing charge. stages of capacity (70% or 75% 1st stage, 100% 2nd d. The 6-1/2 through 12-1/2 ton unit shall have two stage) 3 through 5 ton and (60% 1st stage, 100% 2nd independent refrigerant circuits, equally split in 50% stage)6-1/2 through 12-1/2 ton. capacity increments. UNIT OPERATING CHARACTERISTICS Unit Controls: Unit shall be capable of starting and running at 125 IF a. Unit shall be complete with self-contained low-voltage outdoor temperature, exceeding maximum load criteria control circuit protected by a resettable circuit breaker of AHRI Standard 340/360. The compressor, with on the 24-volt transformer side. standard controls, shall be capable of operation down to b. Unit shall incorporate a lockout circuit which provides 0 IF outdoor temperature. Unit shall be provided with fan reset capability at the space thermostat or base unit time delay to prevent cold air delivery before heat should any of the following standard safety devices trip exchanger warms up. (Gas heat only) and shut off compressor: ELECTRICAL REQUIREMENTS -All unit power wiring • Loss-of-charge/Low-pressure switch. shall enter unit cabinet at a single factory provided • High-pressure switch. location and be capable of side or bottom entry to • Freeze condition sensor on evaporator coil. If any minimize roof penetrations and avoid unit field of these safety devices trip, the LCD screen will modifications. Separate side and bottom openings shall display the alarm message. be provided for the control wiring. c. Unit shall incorporate "AUTO RESET' compressor STANDARD LIMITED WARRANTIES-Compressor—5 over temperature, over current protection. Years, Heat Exchanger— 10 Years, Elect. Heat Elem.—5 d. Unit shall operate with conventional thermostat Years, Parts— 1 Year. designs and have a low voltage terminal strip for easy FACTORY INSTALLED OPTIONAL OUTDOOR AIR hook-up. (Shall be made available by either/or): e. Unit control board shall have on-board diagnostics and fault message display. f. Standard controls shall include anti-short cycle and low voltage protection, and permit cooling operation down to a selectable value as low as 0 OF. g. Control board shall monitor each refrigerant safety switch independently. Information is subject to change without notice.Check local codes. Printed 04/26/2021 MYORK® Guide Specification for , Page 33 York® Sun TM Pro • DRY BULB AUTOMATIC ECONOMIZER—Outdoor and return air dampers that are interlocked and positioned by a fully-modulating, spring-return damper actuator. The maximum leakage rate for the outdoor air intake dampers shall be designed to meet ASHRAE 90.1, AMCA 511 Class 1A damper, and the International Energy Conservation Code (IECC) certification requirements by achieving leakage rates of 3 CFM/sq.ft. at 1" of static pressure. Changeover from compressor to economizer operation shall be provided by an integral electronic enthalpy control that feeds input into the basic module. The outdoor intake opening shall be covered with a rain hood that matches the exterior of the unit. Water eliminator/filters shall be provided. Simultaneous economizer/compressor operation is also possible. Dampers shall fully close on power loss. ADDITIONAL FACTORY INSTALLED OPTIONS • Alternate Indoor Blower Motor—For applications with high restrictions, units are available with optional indoor blower motors that provide higher static output and/or higher airflow. • Powered Convenience Outlet—Unit is provided with an internally powered 120VAC GFCI outlet with cover on the corner of the unit housing the compressors. • Non-Powered Convenience Outlet—Unit is provided with a non-powered 120VAC GFCI outlet with cover on the corner of the unit housing the compressors. • BAS Controls—Include supply air sensor, return air sensor, dirty filter indicator and air proving switch. • Dirty Filter Switch—This kit includes a differential pressure switch that energizes the fault light on the unit thermostat, indicating that there is an abnormally high-pressure drop across the filters. • Smoke Detector—A smoke detector can be factory mounted and wired in the supply and/or return air compartments. FIELD INSTALLED OPTIONS • Smoke Detectors -The smoke detectors stop operation of the unit by interrupting power to the control board if smoke is detected within the air compartment. Information is subject to change without notice Check local codes Printed 04/26/2021 Page:34 Date 04/26/2021 Project Name 04 19981 -Mattituck, NY Project Number Client/ Purchaser Control Summary Page Control Models and Unit Tags � R BAC6'6f'MSTPMdi$6',N-'�-,"O"OM-c6'rd-�,�7 �RTU- vu -2RO'61N12D2B4QC,,,'1,',�2,, 74 Information is subject to change without notice.Check local codes Printed 04/26/2021 MYORK0 SSE Guide Spec Page 35 23 09 23 Direct-digital Control system for HVAC 23 09 23. 13 Decentralized,Rooftop Units 23 09 23. 13.A. Unit Control Board 1. ASHRAE 62-2001 compliant BTL certified. 2. Shall accept 20-30 VAC input power,50/60Hz. 24 VAC nominal. 3. Operating temperature range from-40F to 158F, 10-90%RH(non-condensing UI),and 417 to 15817; 10-90%Rh(non- condensing),with a storage temperature range from-40F to 194F;5-95%RH(non-condensing). 4. Shall include an option of and Economizer microprocessor-controller which communicates directly with the Unit Control Board and has 8 Analog outputs,2 Analog inputs,2 Binary outputs,3 Binary outputs 5. Controller shall accept the followinginputs:space temperature,return air temperature sensor,setpointadjustment,outdoor air temperature,indoor air quality,outdoor air quality,indoor relative humidity,compressor lock-out,fire/smoke shutdown,single and dual enthalpy,fan status,remote time clock,SA Bus communicated temperature/humidity/CO2 values from Network sensors, FC Bus Network Overrides for space temperature,'outdoor air temperature,space humidity,outdoor air quality,Indoor air quality, System purge. 6. Shall accept a single CO2 sensor or multiple CO2 sensors networked together via communication bus in the conditioned space,and be Demand Control Ventilation(DCV)ready. 7. Shall provide the following outputs:economizer,fan,cooling stage 1,cooling stage 2,heat stage 1,heat stage 2,heat stage 3/ exhaust/reversing valve/deliumidify/occupied. 8. Unit shall provide surge protection for the controller through a circuit breaker 9. Shall be Internet capable,and communicate at a Baud rate of 38AK or faster. 10. Shall have an LED display independently showingthe status of activity on the communication bus,and processor operation. 11. Unit shall incorporate a lockout circuit which provides reset capability at the space thermostat or base unit should any of the following standard safety devices trip and shut off compressor. If any of these safety devices trip,the LCD screen will display alarm message indicating the specific safety device that caused the lockout. a. Loss of charge/Low-pressure switch. b. High-pressure switch. c. Freeze condition sensor on evaporator coil. 12. Unit control board must support each usage case: a. Conventional thermostat with low voltage input terminals for easy installation b. Communicating network sensors in the occupied space to provide feedback on space conditions for unit control board to compare with associated setpoints c. Communication via BACnet MS/TP, Modbus RTU, N2 protocols for integration into a building automation/management system 13. Anti-short cycle and low voltage protection features included. 14. Internal occupied/unoccupied scheduling 15. Unit control board shall permit cooling operation down to a selectable value as low as 0 degrees F. 16. Shall allow for start-up, commissioning,troubleshooting, parameter adjustment, setpoint adjustment via onboard display and navigable menu with no additional interface tool or controls technician required. 17. The unit control board shall run a self-test diagnostics algorithm at startup that operated the cooling cycle, heating cycle,fan operation.A status report shall be provided upon completion of the diagnostic self-test. 18. Utilize any wi-fi enabled smart device to access the HVAC or multiple HVAC units if communication wiring between them is present(FC Bus or SA Bus). Remote access shall allow complete ability to perform start-up,commissioning, troubleshooting, parameter adjustment,setpoint adjustment. 19. Local embedded trending and scheduling.Trending data and occupancy scheduling predefined from the factory. Occupancy schedule to be modified via control board joystick menu navigation and remotely using a smart device (cellular phone, laptop, tablet) 20. A menu on the onboard screen shall display the unit status and allow changing parameters where applicable.These include but are not limited to: a. Demand Ventilation Mode—enable or disable b. Operational Setpoint—display current value c. Supply Air Temperature(SAT)—display current value d. Return Air Temperature(RAT)—display current value Information is subject to change without notice.Check local codes Printed 04/26/2021 MY4RK® SSE Guide Spec Page:36 e. Operational Supply Humidity(OprSH)—display current value as provided by a 0-10VDS input, SA Bus Network Sensor, or FC Bus communicated value f. Return Air Humidity(RAH)—display current value g. Operational outdoor Air Temperature(OprOAT)—enthalpy calculated from OAH 0-10VDC input to Economizer board and OprOAT only if economizer is present h. Operational Outdoor Air Humidity(OprOAH)—the buffered outdoor air humidity. May be from economizer boards OAH 0-10VDC input or FC Bus communicated value I. Operational outdoor Air Quality(OprOAQ)—the buffered outdoor air quality in use. May be from economizer boards OAQ 0-10VDC input or FC Bus communicated value j Operational Indoor Air Quality(OprIAQ)—the buffered Indoor air quality in use. May be from economizer board IAQ 0-10VDC input, SA Bus Network Sensor, or FC Bus communicated value 21. A menu shall display and allow modification to the following operations and settings: a. HVAC Zone Fan b. Cooling c. Heating d. Economizer e. Demand Ventilation f. Power Exhaust g. Sensors h. Network 22. A menu shall display and allow modification to the following operations and settings: a. HVAC Zone—Occupied status b. Indoor Fan status c. Cooling status d. Heating status e. Economizer indication whether free-cooling is available or not f. Enabling or disabling of Demand Ventilation g. Power Exhaust 1) Enable/disable hot-gas reheat if available 2) Warmup/Cooldown 3) Title 24 Load Shed 4) Defrost 23. A menu shall display and allow modification to the following operations and settings. a. Firmware version (of UCB, Economizer,other peripheral boards) b. Setting time zone c. Network information 1) Device name that will appear on the FC Bus 2) Selection of communication protocol 3) Operational Baud Rate 4) Device ID 24. A menu shall display and allow modification to the following operations and settings. a. Version of firmware b. Ability to Load new firmware c. Create a backup file of the firmware and parameter setting via USB port d. Restore factory default parameter values and setup e. Full and Partial Cloning of parameter setpoints from or to other units f. Data trend exporting 25. A menu shall display and allow modification to the following operations and settings. Information is subject to change without notice.Check local codes. Printed 04/26/2021 MY4RK® SSE Guide Spec Page 37 a. Unit serial number, model number and name b. Ability to reset Lockouts c. Controller name d. Displays the current values of all setpoints In use e. Displays all current values for the indoor and outdoor zones f. Displays current values related to: 1) Indoor Fan 2) Cooling 3) Heating 4) Heat Pump operation 5) Economizer operation 6) Power Exhaust 7) Demand Ventilation 8) Air monitoring station 9) Hot Gas Reheat 10) Smoke Control g. Current Information for Inputs; including 1) Sensors 2) Coil Sensors 3) Thermostat 4) Binary Inputs 5) Unit Protection 6) Network Inputs 7) All outputs(relay and binary) h. Self-Test 1) A patented self-test system that runs through a series of algorithms to provide a report of all functioning characteristics of the system at time of startup and commissioning. 23 09 23. 13.B. Auxiliary Control Boards 1. ASHRAE 62-2001 compliant. BTL certified. 2. Economizer controller CEC Title 24 Compliant a. Display alarms if the following occur 1) Economizer is economizing when conditions do not support 2) Economizer is not economizing when conditions do support 3) Damper Stuck 4) Excess Outdoor Air 5) Failed Sensor 3. Refrigeration Fault Detection&Diagnostics a. There is insufficient refrigerant in any circuit b. There Is excessive refrigerant in any circuit c. There is excessive refrigerant flow d. There is insufficient refrigerant flow(restriction) e. Inefficient compressor f. Insufficient High-side heat transfer g. Excessive High-side heat transfer(low ambient control problem, low OP) h Insufficient Low-side heat transfer i. Excessive Low-side heat transfer Information is subject to change without notice Check local codes Printed 04/26/2021 MYORK® SSE Guide Spec Page.38 j. Sensor fault-The liquid temperature is greater than the condenser temperature(Could also be triggered If refrigerant level is very low in the system) k. Sensor fault-Sensor data is not available I. The unit Is off m. The ambient temperature is too low n. The ambient temperature is too high o The return air wet-bulb temperature is too low p. The return air wet-bulb temperature is too high q Sensor fault-The condensing temperature is lower than the ambient temperature (Could also be triggered when the condenser is wet) r. The suction line temperature is less than the evaporator temperature s. The evaporator temperature is greater than the ambient temperature t. The liquid temperature is lower than the ambient temperature u. Sensor fault-Suction temperature or ambient temperature is invalid v. Sensor fault-The return air dry-bulb or wet-bulb temperature is invalid w. Sensor fault-The liquid pressure or suction pressure is invalid x. Sensor fault-The suction line temperature Is invalid y. The return air dry-bulb temperature is too low z. The return air dry-bulb temperature is too high aa. The Efficiency Index is below 75%of ideal bb. The Capacity Index Is below 75% of ideal 23 09 23. 13.0 Remote Accessibility: 1. ASHRAE 62-2001 compliant. BTL certified. 2. Provide the ability to adjust parameter values, setpoints, limits remotely 3 Connectivity to an Ethernet network via static IP address or Dynamic Name Server(DNS) 4. Allow a maximum of 100 devices on the same FC bus trunk and accessed by one remote device Information is subject to change without notice Check local codes Printed 04/26/2021 Page 39 START-UP & SERVICE DATA INSTRUCTION COMMERCIAL PACKAGE UNITS 3.0 To 40.0 TONS START-UP CHECKLIST Date Job Name: , Customer Name Address City. State Zip Model Number Serial Number Qualified Start-up Technician Signature HVAC Contractor Phone Address Contractor's E-mail Address Electrical Contractor Phone Distributor Name Phone, WARRANTY STATEMENT This start-up sheet covers all startup check points common to all package equipment In addition It covers essential startup check Johnson,Controls/UPG is confident that this equipment will points for a number of common installation options Depending operate to the owner's satisfaction If the proper procedures are upon the particular unit being started,not all sections of this startup followed and checks are made at initial start-up.This confidence Is sheet will apply Complete those sections applicable and use the supported by the 30 day dealer protection coverage portion of our notes section to record any additional information pertinent to your standard warranty policy which states that Johnson Controls/UPG particular installation will cover parts and labor on new equipment start-up failures that Warranty claims are to be made through the distributor from whom are caused by a defect in factory workmanship or material,for a the equipment was purchased period of 30 days from installation Refer to current standard Warranty policy and warranty manual found on UPGnet for details EQUIPMENT STARTUP In the event that communication with Johnson Controls/UPG is required regarding technical and/or warranty concerns,all parties Use the local LCD or Mobile Access Portal(MAP)Gateway to to the discussion should have a copy of the equipment start-up complete the start-up =sheet for reference A copy of the original start-up sheet should be A copy of-the completed start-up sheet should be kept on file filed with the Technical Services Department by the distributor providing the equipment and a copy,sent to: The packaged unit is available in constant or variable air volume Johnson Controls/UPG versions with a large variety of custom options and accessories Technical Services Department available Therefore;some.vanation in the startup procedure will 5005 York Drive exist depending upon the products capacity,control system, Norman,OK 73069 options and-accessories installed Information is subject to change without notice Check local codes Printed 04/26/2021 Page,40 SAFETY WARNINGS AWARNIWG The Inspections and recording of data outlined in this procedure are required for start-up of Johnson Controls/UPG's packaged products. Industry recognized safety standards and practices Lethal voltages are present during some start-up must be observed at all times General Industry knowledge and checks Extreme caution must be used atall times experience are required,to assure technician safety It is the responsibility of the technician to assess all potential dangers and take-all steps warranted to perform the work in a safe ,WARNING manner By addressing those potential dangers, prior to beginning any work,the technician can perform the work in a safe manner•with minimal risk of injury Moving parts may be exposed during some startup checks Extreme caution must be used at all times, NOTE: Read and reviewthis entire document before beginning any of the startup procedures DESIGN APPLICATION INFORMATION This information will be.available,from the specifying engineer full open position and the frequency drive is operating at 60 HZ who selected-the equipment If'the system`is a VAV system the Do not proceed with the equipment start-up without the CFM will be the airflow when the remote VAV boxes are in the design CFM information. Design Supply Air CFM. Design Return Air CFM Design Outdoor Air CFM At Minimum Position: Total External Static Pressure. Supply Static Pressure: Return Static Pressure- Design Budding Static Pressure: Outside"Air Dilution Economizer Position Percentage _ CFM Supply-Gas Pressure After Regulator W/o Heat Active _ Inches ADDITIONAL APPLICATION NOTES FROM SPECIFYING ENGINEER: Information is subject to change without notice.Check local codes Printed 04/26/2021 Page:41 REFERENCE General Inspection Completed See Notes Unit Inspected for shipping,storage,or rigging damage ❑ ❑ Unit Installed with proper clearances ❑ ❑ Unit Installed within slope limitations ❑ ❑ Refrigeration system checked for gross leaks(presence of oil) ❑ ❑ Terminal screws and wiring connections checked for tightness ❑ ❑ Filters Installed correctly and clean ❑ ❑ Economizer hoods Installed in operating position ❑ ❑ Condensate drain trapped properly, refer to Installation Manual ❑ ❑ Economizer damper linkage tight ❑ ❑ Gas Heat vent hood-installed ❑ ❑ All field wiring(power and control)complete ❑ ❑ Air Moving Inspection Completed See Notes Alignment of drive components ❑ ❑ Belt tension adjusted properly ❑ ❑ Blower pulleys tight on shaft, bearing set screws tight,wheel tight-to shaft ❑ ❑ Pressure switch or transducer tubing Installed properly ❑ ❑ Exhaust Inspection Powered❑. Barometric Relief❑ Completed See Notes Check hub for tightness ❑ ❑ Check fan blade for clearance ❑ ❑ Checkfor proper rotation ❑ ❑ Check for proper mounting(screen faces towards unit) ❑ ❑ Prove operation by increasing minimum setting on economizer ❑ ❑ Economizer Inspection Standard❑ BAS❑ Completed See Notes CO2 sensor installed Yes❑ No❑ ❑ ❑ Check economizer setting(Reference SSE Control Board LCD menu location) ❑ ❑ Prove economizer open/close through SSE Board Setting ❑ ❑ Reheat Mode Normal 0 or Alternate❑ Not Applicable❑ Humidity Sensor(2SH0401) Information is subject to change without notice Check local codes. Printed 04/26/2021 Page,42 Operating Measurements -Air Flow Fan operates voth proper rotation ID Fans❑ Foch Fans❑ Cond Fans❑ Pressure drop across dry evaporator coil(At maximum design CFM) IWC External Static Pressure IWC Return Static Pressure - SWC Supply Static Pressure IWC Supply Air CFM Using Dry Coll Chart CFM Final Adjusted Supply Air CFM2 CFM 1 Consult the proper airflow to pressure drop table to obtain the actual airflow at the measured pressure differential 2 Was'a motor pulley adjustment or change required to obtain the correct'airflow? Was it necessary to increase of decrease the airflow to meet the design conditions? If the motor pulley size was changed;measure the outside diameters of the motor and blower pulleys and record those diameters here, Blower Motor HP FLA RPM Pulley Pitch Diameter Turns Out Final Turns Out Blower Pulley Pitch Diameter Fixed Sheave ELECTRICAL DATA T1 -T2 Volts T2-T3 Volts Control Voltage Volts T1 -T3 Volts Device Nameplate Measured List All Three Amperages Supply Fan Motorl,2AMPS AMPS Exhaust Motor(Dampers 100%) AMPS AMPS Condenser Fan#1 AMPS AMPS Condenser Fan#2(if equipped) AMPS -AMPS Condenser Fan#3(If equipped) AMPS AMPS Condenser Fan#4(if equipped) AMPS AMPS Compressor#1 AMPS AMPS Compressor#2(if equipped) AMPS AMPS Compressor#3(If equipped), AMPS AMPS Compressor#4(if equipped) AMPS AMPS 1 VAV units with heat section-simulate heat call to drive VAV boxes and VFD/IGV to maximum design airflow position 2 VAV units without heat section-VAV boxes must beset to maximum design airflow position Information is subject to change without notice Check local codes Printed 04/26/2021 Page:43 OPERATING MEASUREMENTS -COOLING Discharge Discharge Liquid Line 2 Suction Suction Stage Pressure Temp. Tempa Subcooling Pressure Temp. Superheat First # ° ' # o ° Second(d equipped) # o o D # ° Third(if equipped) # o o o # o ° Fourth'(If equipped) # o o 1 # ° Reheat 1 st Stage 1 #1 o Iol 1 # ° 1 Liquid temperature should be taken before filter/dner 2 Subtract.l0 psi from discharge pressure for estimated liquid line pressure Outside air temperature °F db °F wb %RH Return Air Temperature °F db °F wb %RH Mixed Air Temperature °F db °F wb %RH Supply Air Temperature °F db °F wb %RH REFRIGERANT SAFETIES Action Completed See Notes Prove Compressor Rotation(3 phase only)by gauge pressure ❑ ❑ Prove High Pressure Safety,All Systems ❑ ❑ Prove Low`Pressure Safety,All Systems ❑ ❑ OPERATING MEASUREMENTS -GAS HEATING Fuel Type ❑ Natural Gas ❑ LP Gas Action Completed See Notes Check for gas leaks ❑ ❑ Prove Ventor Motor Operatibn ❑ ❑ Prove Primary Safety Operation ❑ ❑ Prove Auxiliary Safety Operation ❑ ❑ Prove Rollout Switch.Operation ❑ ❑ Prove Smoke Detector Operation ❑ ❑ Stage 1 IWC ❑ Manifold Pressure Stage 2(If Equipped) IWC ❑ Stage 3(If Equipped) IWC ❑ Supply gas pressure at full fire IWC ❑ Check.temperature,risel ❑ measured at full fire °F ❑ 1 input X Eff (BTU outout), 1 08 X Temp Rise Information is subject to change without notice Check local codes Pnnted 04/26/2021 Page:44 OPERATIONAL MEASUREMENTS -STAGING CONTROLS Verify Proper,Operation of Heatirfg/Cooling Staging Controls Create a cooling demand,at the Thermostat,BAS System or Simplicity SE Verify that cooling/economiser stages are energized. ❑ Create a heating demand at the Thermostat, BAS System or Simplicity SE Verify that heating stages are energized ❑ Verify Proper Operation of the Variable Frequency Drive(If Required) Verify that motor speed modulates with duct pressure change ❑ FINAL -INSPECTION Verify that all operational control set points have been set fo desired value ❑ Scroll through all setpoints and change as may be necessary to suit the occupant requirements Verify that all option parameters are correct Scroll through all option parameters and ensure that all Installed options are enabled In the software and all ❑ others are.disabled in the software '(Factory software settings should match the Installed options) Verify that all access panels have been closed and secured ❑ OBSERVED PRODUCT DIFFICIENCIES & CONCERNS: Information is subject to change without notice Check local codes Printed 04/2612021